ELDORADO AXESS Recalls

Oct 31, 2014 – Eldorado National-California, Inc. (Eldorado) is recalling certain model year 2008-2009 Axess, E-Z Rider II, XHF, Escort RE-A, and Transmark RE vehicles manufactured April 1, 2008, to December 30, 2008. The mechanical springs used to return the accelerator pedal to idle after the driver lifts their foot off the pedal may break.

Feb 04, 2014 – Eldorado National (California), Inc. (Eldorado) is recalling certain model year 2005-2012 Axess, 2006-2013 E-Z Rider II and 2013 Passport buses equipped with Sure Power-brand battery equalizers or DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

Oct 19, 2012 – Eldorado National is recalling certain model year 2011 Axess and EZ Rider II Max buses, manufactured between October 1, 2010 and October 31, 2010 and equipped with Ricon 3-Minute Urban Transit Bus egress window sets. The composition of the material used to cast the handle that opens the egress window is incorrect, resulting in a reduction in material strength. The handle(s) on the emergency egress passenger windows may break before the window latch is released.

Sep 25, 2012 – Eldorado National-California (Eldorado) is recalling certain model year 2006-2008 vehicles equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.

Aug 22, 2011 – ELDORADO IS RECALLING CERTAIN MODEL YEAR 2011 COMMERCIAL BUSES, MODELS EZ RIDER II MAX, TRANSMARK, XHF, AND AXESS, MANUFACTURED FROM NOVEMBER 1, 2010, THROUGH MARCH 31, 2011, EQUIPPED WITH A CUMMINS ISB, ISL, ISC, OR ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Oct 13, 2009 – ELDORADO NATIONAL IS RECALLING CERTAIN MODEL YEAR 2002-2010 TRANSIT BUSES, EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

Feb 15, 2008 – ELDORADO NATIONAL - CALIFORNIA (ENC) IS RECALLING 106 MY 2004-2007 AXESS, E-Z RIDER II AND TRANSMARK RE REAR ENGINE BUSES BUILT WITH CUMMINS ISL AND ISC DIESEL ENGINES AND EQUIPPED WITH THE CM850 FUEL SYSTEM. THE ENGINE HIGH PRESSURE FUEL LINES FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL ARE PRONE TO FAILURE. THE FUEL LINE FAILURES HAVE BEEN DETERMINED TO BE CAUSED BY PROLONGED VIBRATION. FAILURE TYPICALLY OCCURS AT OR UNDER THE FUEL LINE FITTING ATTACHMENTS. FAILURE OF THE FUEL LINE INTRODUCES HIGH PRESSURE ATOMIZED DIESEL FUEL INTO THE ENGINE COMPARTMENT.