ELDORADO TRANSMARK Recalls

Oct 29, 2015 – Eldorado National-California, Inc. (Eldorado National) is recalling certain model year 2006-2007 MST and Transmark vehicles manufactured January 1, 2006, to December 30, 2007, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Oct 31, 2014 – Eldorado National-California, Inc. (Eldorado) is recalling certain model year 2008-2009 Axess, E-Z Rider II, XHF, Escort RE-A, and Transmark RE vehicles manufactured April 1, 2008, to December 30, 2008. The mechanical springs used to return the accelerator pedal to idle after the driver lifts their foot off the pedal may break.

Sep 30, 2014 – Eldorado National-California, Inc. (Eldorado National) is recalling certain model year 2006-2007 MST, and Transmark transit buses manufactured January 1, 2006, to December 30, 2007, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Sep 25, 2012 – Eldorado National-California (Eldorado) is recalling certain model year 2006-2008 vehicles equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.

Aug 22, 2011 – ELDORADO IS RECALLING CERTAIN MODEL YEAR 2011 COMMERCIAL BUSES, MODELS EZ RIDER II MAX, TRANSMARK, XHF, AND AXESS, MANUFACTURED FROM NOVEMBER 1, 2010, THROUGH MARCH 31, 2011, EQUIPPED WITH A CUMMINS ISB, ISL, ISC, OR ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Mar 25, 2010 – ELDORADO NATIONAL - CALIFORNIA HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2005-2010 TRANSIT BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Oct 13, 2009 – ELDORADO NATIONAL IS RECALLING CERTAIN MODEL YEAR 2002-2010 TRANSIT BUSES, EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

Feb 15, 2008 – ELDORADO NATIONAL - CALIFORNIA (ENC) IS RECALLING 106 MY 2004-2007 AXESS, E-Z RIDER II AND TRANSMARK RE REAR ENGINE BUSES BUILT WITH CUMMINS ISL AND ISC DIESEL ENGINES AND EQUIPPED WITH THE CM850 FUEL SYSTEM. THE ENGINE HIGH PRESSURE FUEL LINES FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL ARE PRONE TO FAILURE. THE FUEL LINE FAILURES HAVE BEEN DETERMINED TO BE CAUSED BY PROLONGED VIBRATION. FAILURE TYPICALLY OCCURS AT OR UNDER THE FUEL LINE FITTING ATTACHMENTS. FAILURE OF THE FUEL LINE INTRODUCES HIGH PRESSURE ATOMIZED DIESEL FUEL INTO THE ENGINE COMPARTMENT.

Jan 29, 2008 – CERTAIN BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Jan 29, 2008 – ELDORADO NATIONAL - CALIFORNIA (ENC) IS RECALLING 21 MY 2005-2007 MST, MST II AND TRANSMARK BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS MANUFACTURED FROM APRIL 2005 TO JUNE 2007. THE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.