ELDORADO Recalls

Sep 23, 2003 – ON CERTAIN BUSES EQUIPPED WITH CUMMINS ELECTRONIC CONTROL MODULES ON THE L10G ENGINES, THE ECM DOES NOT HAVE THE ABILITY TO DETECT A THROTTLE FAIL-SAFE ENGINE SHUTDOWN COMMAND. THIS COULD RESULT IN AN UNANTICIPATED, UNCOMMANDED OPEN THROTTLE CONDITION WITHOUT WARNING.

May 14, 2003 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.

Oct 18, 2002 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY. THE SEAT BELT SUPPLIER, AMSAFE, WILL PROVIDE A SNAP ON "OVER-COVER" TO OWNERS TO PREVENT THE SEAT BELT COVER FROM SEPARATING.

May 14, 2002 – ON CERTAIN TRAILERS EQUIPPED WITH BENDIX SR-2, SR-4, AND SR-5 TRAILER SPRING BRAKE VALVE ASSEMBLIES, THE MOLDED RUBBER FACE OF THE INLET/EXHAUST VALVE (I/E VALVE) COMPONENT OF THE AFFECTED VALVES CAN SEPARATE FROM THE VALVE'S METAL INSERT. AIR CAN BE TRAPPED BY A SEPARATED I/E VALVE CAUSING IT TO BALLOON AND BLOCK THE EXHAUST PASSAGE OF THE TRAILER SPRING BRAKE CIRCUIT.

Mar 15, 2002 – ON CERTAIN BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.

Mar 01, 2002 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH ADHESIVELY BONDED ALUMINUM BUS DOOR PANELS, DUE TO AN IMPERFECT BONDING OF THE DOOR PANEL SKIN TO THE PANEL FRAME, ENVIRONMENTAL MOISTURE MAY INFILTRATE REGIONS OF IMPERFECT BONDING AND CAUSE SEPARATION OF THE FRAME AND DOOR PANEL.

Nov 09, 2001 – VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH MERITOR WABCO PHASE 1, D-VERSION ANTILOCK BRAKE SYSTEM (ABS), FAIL TO COMPLY TO THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." AN INTERNAL DIAGNOSTIC SYSTEM IN THE ABS MAY NOT DETECT AN EXTREME WHEEL SPEED SENSOR AIR GAP. SUCH A CONDITION COULD POSSIBLY OCCUR DURING (1) ORIGINAL ASSEMBLY OR (2) SUBSEQUENT WHEEL END SERVICE.

Jul 02, 2001 – VEHICLE DESCRIPTION: TRANSIT AND SHUTTLE BUSES EQUIPPED WITH CUMMINS ISC AND ISL DIESEL ENGINES. THE INTERNAL FRONT BUSHING CAN SPIN, CAUSING DAMAGE TO THE AIR COMPRESSOR, AND POSSIBLY TO THE SPINDLE DRIVE AT THE REAR FACE OF THE AIR COMPRESSOR WHICH IS USED TO PROVIDE POWER TO THE VEHICLE HYDRAULIC PUMP. FAILURE OF THE AIR COMPRESSOR'S SPINDLE DRIVE COULD LEAD TO LOSS OF POWER ASSIST IF THE HYDRAULIC PUMP CEASES TO OPERATE.

Apr 07, 2000 – VEHICLE DESCRIPTION: REAR ENGINE BUSES. THESE BUSES ARE POWERED BY A CNG ENGINE AND COPPER TUBING WAS USED AS VENT LINES.

Aug 17, 1998 – VEHICLE DESCRIPTION: BUSES BUILT ON A CHEVROLET GMT 600 CUTAWAY CHASSIS WITH A GRANNING TAG AXLE ADDED. WHEN THE WHEELS WERE INSTALLED ON THE TAG AXLE, THE RETAINING RING THAT GOES BETWEEN THE WHEEL AND THE LUG NUTS WAS INADVERTENTLY LEFT OFF.