FLEETWOOD STORM Recalls

May 24, 2011 – FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2011 BOUNDER CLASSIC, STORM AND TERRA CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 21, 2010, THROUGH FEBRUARY 11, 2011. CERTAIN MODEL YEAR 2011 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 24, 2010 THROUGH MAY 18, 2011; AND CERTAIN MODEL YEAR 2012 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 16, 2011 THROUGH JUNE 15, 2011. A WIRE HARNESS THAT IS ROUTED UNDER THE MOTOR HOME, NEAR THE CHASSIS RAIL, CAN CONTACT A HEAT SHIELD LOCATED NEXT TO THE PASSENGER SIDE ENGINE EXHAUST MANIFOLD. THE CLOSE PROXIMITY CAN CAUSE THE HARNESS TO MELT OR BE OTHERWISE DAMAGED.

Oct 29, 2010 – FLEETWOOD IS RECALLING CERTAIN CLASS-A AND CLASS-C MOTOR HOMES EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Jun 28, 2010 – FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2010 ENCOUNTER AND MODEL YEAR 2011 STORM 28MS CLASS A MOTOR HOMES MANUFACTURED FROM DECEMBER 16, 2009 THROUGH JULY 1, 2010. AN EMERGENCY EGRESS WINDOW WAS NOT INSTALLED IN THE ROAD SIDE BEDROOM WALL. IN THE EVENT OF A FIRE OR OTHER EMERGENCY, PERSONS IN THE BEDROOM AREA MUST EXIT THROUGH THE DOOR SIDE BEDROOM EMERGENCY EGRESS WINDOW OR THROUGH THE FORWARD ENTRY DOOR.

Jun 02, 2009 – FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Jul 15, 2008 – FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Mar 19, 2007 – CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Oct 04, 2006 – ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.

Jun 19, 2006 – ON CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.

Apr 12, 2006 – CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 "CONTROLS AND DISPLAYS" AND NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

Feb 23, 2006 – ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.