FREIGHTLINER COLUMBIA Recalls

Dec 15, 2004 – ON CERTAIN VEHICLES, THERE IS A DEFECT IN THE INTERAXLE DRIVELINE YOKES. THE BOLT HOLES LOCATED ON THE EARWORK OF THE MALE SHAFT YOKES WERE MANUFACTURED WITH AN OVERSIZED MINOR THREAD DIAMETER.

May 04, 2004 – ON CERTAIN TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, THE TAPERED JOINT THAT ATTACHES THE SHIFTER TO THE TRANSMISSION MAY BECOME LOOSE MAKING IT DIFFICULT TO PUT THE TRANSMISSION INTO GEAR.

Dec 04, 2003 – ON CERTAIN TRUCKS EQUIPPED WITH AIR BRAKES, THE PLASTIC PUSH-TO-CONNECT AIR LINE FITTING CARTRIDGE COULD BE IMPROPERLY WELDED INTO THE NYLON JUNCTION BLOCK HOUSING ALLOWING AN AIR LINE TO BECOME DISCONNECTED.

Jun 17, 2003 – ON CERTAIN TRUCK TRACTORS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.

Mar 21, 2003 – ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

Dec 02, 2002 – ON CERTAIN TRUCKS EQUIPPED WITH MANIFOLD DASH VALVES WITH PUSH TO CONNECT FITTINGS USED TO CONTROL THE PARK BRAKE FUNCTION ON TRUCKS AND TRAILERS WITH AIR BRAKES, THE PARK KNOB CAN POP OUT UNEXPECTEDLY WHILE THE VEHICLE IS IN MOTION. THIS WILL EXHAUST THE AIR FROM THE PARK BRAKE SYSTEM ON THE TRAILER AND APPLY THE PARKING BRAKES.

Aug 07, 2000 – VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.