FREIGHTLINER MB Recalls

Feb 25, 2015 – Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Oct 05, 2005 – CERTAIN 2004 AND 2005 FREIGHTLINER VAN, MOTOR HOME, SHUTTLE BUS, AND SCHOOL BUS CHASSIS MANUFACTURED BETWEEN JANUARY 2004 AND MAY 2005. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE WEAR OF THE PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL LIFT PUMP FAILURE AND IN SOME CASES MAY CAUSE AN ENGINE STALL CONDITION.

Apr 27, 2005 – CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.

Jun 09, 2004 – ON CERTAIN SHUTTLE BUS CHASSIS, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.

Jun 09, 2004 – ON CERTAIN SHUTTLE BUS CHASSIS, DUE TO THE LOCATION OF THE 90 GALLON FUEL TANK, A LEAK IN A WELD WHERE THE TANK CONTACTS THE LOWER FUEL TANK SUPPORT CAN OCCUR.

Dec 04, 2003 – ON CERTAIN SCHOOL BUS, XC RV, AND SHUTTLE BUS CHASSIS MANUFACTURED BETWEEN FEBRUARY 1 AND JULY 18, 2003, INCORRECT AXLE STEERING STOP BOLTS WERE INSTALLED ON AAC FRONT AXLES. IT MAY BE POSSIBLE TO TURN THE FRONT WHEELS IN EITHER DIRECTION UNTIL THE TIRES CONTACT OR DAMAGE OTHER STEERING COMPONENTS.

Sep 22, 2000 – VEHICLE DESCRIPTION: SHUTTLE BUSES, RECREATIONAL VEHICLES, UTILITY VANS, AND HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR WABCO PHASE 1, D-VERSION ANTILOCK BRAKE SYSTEM (ABS), FAIL TO COMPLY TO THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." AN INTERNAL DIAGNOSTIC SYSTEM IN THE ABS MAY NOT DETECT AN EXTREME WHEEL SPEED SENSOR AIR GAP. SUCH A CONDITION COULD POSSIBLY OCCUR DURING (1) ORIGINAL ASSEMBLY OR (2) SUBSEQUENT WHEEL END SERVICE.

Aug 17, 2000 – VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, SHUTTLE BUSES, TRANSIT BUSES AND STEP VANS EQUIPPED WITH ALLISON 1000 OR 2400 SERIES TRANSMISSIONS. THESE TRANSMISSIONS CAN EXPERIENCE PARK PAWL TO REAR COVER INTERFERENCE DUE TO AN OUT OF FLATNESS CONDITION.

Jul 21, 1998 – VEHICLE DESCRIPTION: WALK-IN VAN AND SHUTTLE BUS CHASSIS EQUIPPED WITH MERITOR MODEL FC-921 FRONT AXLES. STRESS CRACKS CAN OCCUR IN THE LEFT FRONT AXLE STEERING KNUCKLE.

Sep 02, 1997 – VEHICLE DESCRIPTION: MEDIUM AND HEAVY DUTY TRUCKS CHASSIS EQUIPPED WITH ALLISON 500 SERIES TRANSMISSION AND A BENDIX 9X3 POWER APPLY PARK BRAKE SYSTEM. THE CAM LEVER OF THE POWERED APPLY BRAKE CAN MOVE FORWARD, BECAUSE A HOLE IN THE TRANSMISSION MOUNTING BOSS WAS DRILLED TOO DEEP.