JAYCO LEGACY Recalls

Nov 21, 2017 – Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Dec 17, 2010 – JAYCO IS RECALLING CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Sep 21, 2010 – JAYCO IS RECALLING CERTAIN MODEL YEAR 2004 LEGACY AND MODEL YEAR 2005 DESIGNER FIFTH WHEEL TRAILERS EQUIPPED WITH DIMPLEX ELECTRAFLAME, SYMPHONY, OR OPTIFLAME BRANDED ELECTRIC FIREPLACES, STOVES, AND FIREPLACE INSERTS. THE PLUG IN REMOTE CONTROL RECEIVER FOR THE FIREPLACE CAN OVERHEAT.

Jul 23, 2009 – JAYCO IS RECALLING 273 MODEL YEAR 2002-2004 LEGACY FIFTH WHEEL MOTORHOMES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Mar 31, 2009 – JAYCO IS RECALLING 46 MY 2009 LEGACY SERIES 37RLSA AND 36RLMS FIFTH WHEEL TRAILERS. THERE MAY BE A MISSING GROUND WIRE BETWEEN THE TRAILER FRAME AND THE 12-VOLT BUS BAR.

Sep 11, 2008 – JAYCO IS RECALLING 28 MY 2009 LEGACY FIFTH WHEEL TRAVEL TRAILERS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THERE IS A TYPOGRAPHICAL ERROR INCORRECTLY STATING THE TIRE LOAD RANGE AND THE INFLATION PRESSURE ON THE FEDERAL IDENTIFICATION LABEL FOR THE REAR AXLE.

Jul 21, 2004 – ON CERTAIN TRAVEL TRAILERS, DUE TO VARIOUS FACTORS, INCLUDING EXCESSIVE PAINT COATING ON THE BRAKE HUB, THE ALUMINUM WHEELS COULD EXHIBIT LESSENED CLAMPING PRESSURE BETWEEN THE ALUMINUM WHEEL AND THE AXLE HUB ASSEMBLY.

Oct 09, 2003 – ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.