NEW FLYER C40LF Recalls

Jul 22, 2010 – NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2008 C40LFR, D40LF AND DE60LF HEAVY DUTY TRANSIT BUSES, AS WELL AS MODEL YEAR 2009 DE60LFA HEAVY DUTY TRANSIT BUSES. THE PASSENGER ASSIST GRAB STRAP HANDLES HAVE EXPERIENCED MULTIPLE FAILURES IN THE FIELD.

Mar 09, 2010 – NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2004-2009 TRANSIT BUSES. THESE MODELS HAVE AN INSPECTION PANEL LOCATED ABOVE THE DRIVE SHAFT IN THE PASSENGER COMPARTMENT FLOORING FOR EASY INSPECTION AND REMOVAL OF THE DRIVE SHAFT. THIS PANEL MAY NOT BE OF SUFFICIENT STRENGTH TO PREVENT FOREIGN MATTER FROM ENTERING THE PASSENGER COMPARTMENT IN THE EVENT OF A DRIVE SHAFT FAILURE.

Sep 24, 2009 – NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

Jul 03, 2008 – NEW FLYER IS RECALLING 319 MY 2008 C40LF, C40LFR, D35LF, D40LF, D41LF, D61LFR, DE41LF, DE61LF, E40LFR, GE40LFR, AND DE41LFR TRANSIT BUSES EQUIPPED WITH PARKER HANNIFIN (VANSCO) CONTROL MODULES. A CERTAIN BATCH OF THE PROGRAMMABLE LOGIC CONTROL MODULES MAY HAVE A MANUFACTURING DEFECT. THIS DEFECT COULD PRODUCE ERRATIC BEHAVIOR OF CERTAIN INPUT/OUTPUT SIGNALS TO AND FROM THE AFFECTED MODULE. THIS ERRATIC BEHAVIOR COULD POTENTIALLY IMPACT CERTAIN FUNCTIONS SUCH AS THE HEADLIGHTS, BRAKE LIGHTS, THROTTLE CONTROL, AND CONTROL OF THE ARTICULATED JOINT.

Jan 09, 2008 – CERTAIN BUSES HAVE STAINLESS STEEL HYDRAULIC LINES WITH 90º FLANGE FITTINGS WHICH ARE SUBJECT TO FAILURE DUE TO ERRORS IN BOTH THE DESIGN AND MANUFACTURE OF THESE LINES.

Jun 11, 2007 – ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.

Mar 13, 2007 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH GRAHAM WHITE AIR DRYERS, THE AIR DRYER TIMER MODULES MAY ALLOW SUFFICIENT QUANTITIES OF MOISTURE TO ENTER AND AFFECT THE OPERATION OF THE VEHICLE AIR BRAKE SYSTEM.

Feb 23, 2007 – CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.

Feb 07, 2006 – ON CERTAIN TRANSIT BUSES, THE SPOT WELDS WHICH HOLD THE WHEELCHAIR RAMP HINGE ASSEMBLY TOGETHER CAN FAIL ALLOWING THE RAMP TO SEPARATE, WHEN DEPLOYED UNDER LOAD, FROM THE BUS FRAME.

Jan 18, 2006 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH RELAY VALVES BUILT BY HALDEX/MIDLAND AND DISTRIBUTED BY MERITOR/WABCO WITH VALVE BODY DATE CODE OF 342A4K. THIS VALVE, WHICH IS INSTALLED IN THE REAR AXLE AIR BRAKE CIRCUIT, CAN FAIL RESULTING IN A LOSS OF AIR PRESSURE TO THE REAR SERVICE BRAKES.