ORION Recalls

Mar 23, 2004 – ON CERTAIN BUSES EQUIPPED WITH CUMMINS ELECTRONIC CONTROL MODULES ON THE L10G ENGINES, THE ECM DOES NOT HAVE THE ABILITY TO DETECT A THROTTLE FAIL-SAFE ENGINE SHUTDOWN COMMAND. THIS COULD RESULT IN AN UNANTICIPATED, UNCOMMANDED OPEN THROTTLE CONDITION WITHOUT WARNING.

Mar 27, 2003 – CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.

Feb 24, 2003 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50 ENGINE CONFIGURATIONS, A HYDRAULIC MOTOR USED TO DRIVE THE ENGINE COOLING FAN MOTOR HAS TWO HOSES CONNECTED TO IT, INCLUDING A HIGH PRESSURE INPUT HOSE. THE HIGH PRESSURE HOSE IS CONSTRUCTED WITH REUSABLE OR CRIMP ENDS. THE HYDRAULIC MOTOR IS LOCATED AT THE REAR OF THE BUS, INSIDE THE ENGINE COMPARTMENT. THE END OF THE HOSE THAT IS CONNECTED TO THE FAN MOTOR HAS DISCONNECTED FROM THE HOSE CONNECTOR.

Nov 15, 2001 – VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS, FIRE TRUCKS, AND TRANSIT BUSES AND SCHOOL BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.

Feb 21, 2001 – VEHICLE DESCRIPTION: TRUCKS, SCHOOL BUS AND MOTOR HOME CHASSIS, AND TRANSIT BUSES EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.

Jan 29, 2001 – VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM.

Sep 08, 1999 – VEHICLE DESCRIPTION: TRANSIT BUSES. FAILURE OF A SOFT SEAT CHECK VALVE IN WHEELCHAIR LIFTS PROVIDED BY LIFT-U, MAY ALLOW THE FRONT AND REAR PLATFORM BARRIERS TO RETURN TO A HORIZONTAL POSITION FROM THE VERTICAL POSITION THEY ARE SUPPOSED TO BE LOCKED IN.

Dec 22, 1998 – VEHICLE DESCRIPTION: LOW-FLOOR TRANSIT BUSES EQUIPPED WITH A CAST STEEL STEERING RELAY ARM. THE STEERING ARMS CAN FAIL WITHOUT WARNING.

Sep 21, 1998 – VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH WHEEL CHAIR BARRIERS. THE WHEEL CHAIR BARRIERS ARE ATTACHED TO THE FLOOR STRUCTURE WITH A BOLT THREADED INTO THE FLOOR STRUCTURE. IN THE CASE OF A FRONTAL CRASH, WITH THE WHEEL CHAIR POSITION OCCUPIED, THE BOLT THREADS COULD STRIP ALLOWING MOVEMENT OF THE WHEEL CHAIR BARRIER.

Sep 17, 1998 – VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH ELECTRIC ENGINE STARTERS. THE POWER CABLES ARE ROUTED ACROSS THE BACK OF THE ENGINE AND FASTENED TO THE ENGINE BULKHEAD. THE CABLE MAY NOT BE ADEQUATELY FASTENED, CHAFFING THE CABLE, AND CAUSING AN ELECTRICAL SHORT.