OSHKOSH Recalls

Sep 20, 1995 – A STOP LIGHT SWITCH ON THE BRAKE TREADLE VALVE AND A CRUISE CONTROL DUMP VALVE SWITCH WERE OMITTED DURING ASSEMBLY OR BOTH SWITCHES WERE INSTALLED BUT WERE NOT WIRED CORRECTLY.

Aug 01, 1995 – AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.

Jul 20, 1995 – A BRACKET INSTALLED TO SECURE A HIGH IDLE COMPONENT ONTO THE ENGINE THROTTLE ARM CAN HOOK THE WIRE HARNESS AND PREVENT ITS RETURN TO IDLE SPEED.

Jul 20, 1995 – THE FUEL TANK STRAP CAN BREAK ALLOWING A SLIGHT UPWARD MOVEMENT OF THE TANK. A DUAL FUEL TANK STRAP BREAKAGE CAN ALSO ALLOW THE TANK TO SLIDE FORWARD OR REARWARD.

Jul 13, 1995 – THIS STEERING GEAR CAN FAIL FROM FATIGUE CAUSED BY HIGH TWISTING FORCES THAT CAN OCCUR IN CERTAIN SEVERE DAILY USE SUCH AS TURNING THE STEERING WHEEL UP AGAINST THE AXLE STOPS WHEN THE VEHICLE IS NOT ON DRY PAVEMENT.

Feb 09, 1995 – AIR COMPRESSOR GOVERNOR SENSING LINE DOES NOT SENSE BOTH FRONT AND REAR BRAKE SYSTEM RESERVOIR PRESSURE. A FRONT BRAKE SYSTEM AIR LEAK WILL NOT BE SENSED BY THE GOVERNOR AND THE COMPRESSOR WILL FAIL TO RESUPPLY THE FRONT AIR SYSTEM CAUSING A REDUCTION OF THE FRONT BRAKE SYSTEM PERFORMANCE.

Feb 07, 1995 – METRIC GRADE 8.8 BOLTS WERE MIXED IN INVENTORY WITH METRIC GRADE 10.9 BOLTS. INCORRECT GRADE BOLTS (8.8) WERE USED IN ATTACHING THE 710 SAGINAW STEERING GEAR TO THE FRAME.

Feb 07, 1995 – TWO OF THE FOUR BOLT-AND-WASHER COMBINATIONS USED TO SECURE THE 710 SAGINAW STEERING GEAR TO THE CHASSIS FRAME HAD DIFFERENT WASHER MATERIAL THICKNESSES. THIS CAN AFFECT THE BOLT THREAD ENGAGEMENT INTO THE STEERING GEAR CAUSING LOOSE STEERING GEAR BOLTS.

Jul 19, 1994 – DEPENDING ON THE LOCATION AND THE ELECTRICAL DEMAND, A COMBINATION OF CORROSION AND HEAT CAN CAUSE A MOMENTARY BREAK ON EITHER OF TWO ELECTRICAL CIRCUITS AT THE BULKHEAD CONNECTOR (21 OR 29). IF THESE CIRCUITS FAIL, THE IGNITION, PARKING LIGHT, FUEL PUMP, FUSE PANELS AND THE SECONDARY ELECTRICAL BRAKING SYSTEM WILL LOSE POWER.

Jun 10, 1994 – THE AIR COMPRESSOR AIR SUPPLY LINE IS ROUTED FROM THE COMPRESSOR OVER THE TOP OF THE FRAME RAIL, UNDER THE BRAKE HYDROMAX, AND DOWN TO THE AIR SYSTEM. THIS LINE CAN CONTACT THE STEEL SECTION OF THE HYDROMAX HYDRAULIC SUPPLY LINE, CAUSING A LEAK TO OCCUR IN THE HYDRAULIC LINE, ALLOWING HYDRAULIC FLUID TO LEAK ON THE LEFT FRONT WHEEL AND BRAKE ASSEMBLY.