STARTRANS SENATOR Recalls

Apr 27, 2012 – STARTRANS IS RECALLING CERTAIN MODEL YEAR 2007-2010 TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED. SEE THE ABOVE LIST FOR THE AFFECTED MODELS.

Apr 11, 2011 – STARTRANS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 TRANSIT BUSES EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Nov 15, 2010 – STARTRANS IS RECALLING CERTAIN MODEL YEAR 2006 AND 2007 CANDIDATE, CANDIDATE II, SENATOR HD, TROLLEY, PRESIDENT, SENATOR, AND SENATOR II TRANSIT BUSES EQUIPPED WITH TRANS/AIR TA73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE.

May 10, 2010 – STARTRANS BUS IS RECALLING CERTAIN MODEL YEAR 2009 CANDIDATE, CANDIDATE II, SENATOR, SENATOR HD, PRESIDENT, TROLLEY, AND SENATOR II TRANSIT BUSES MANUFACTURED FROM SEPTEMBER 2007 THROUGH DECEMBER 18, 2009, AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

May 10, 2010 – STARTRANS BUS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 CANDIDATE, CANDIDATE II, SENATOR, SENATOR HD, PRESIDENT, TROLLEY, SENATOR II, AND SENTINAL TRANSIT BUSES MANUFACTURED FROM DECEMBER 2007 THROUGH DECEMBER 18, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Oct 19, 2009 – STARTRANS IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 15, 2001 AND SEPTEMBER 24, 2009, EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.

Oct 19, 2009 – STARTRANS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN AUGUST 9, 2006 AND JUNE 25, 2009, EQUIPPED WITH TRANS/AIR AIR CONDITIONING SYSTEMS. EACH TRANS/AIR SYSTEM COMES WITH AN ELECTRICAL KIT AND EC PC BOARD WHICH IF IMPROPERLY INSTALLED COULD OVERHEAT.

Dec 01, 2008 – STARTRANS IS RECALLING 4,409 MY 2004-2008 SENATOR AND CANDIDATE SHUTTLE BUSES BUILT ON FORD OR CHEVROLET CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Dec 01, 2008 – STARTRANS IS RECALLING 4,409 MY 2004-2008 SENATOR AND CANDIDATE SHUTTLE BUSES BUILT ON FORD OR CHEVROLET CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.