STERLING Recalls

Dec 22, 2004 – CERTAIN MICHELIN XDE COMMERCIAL TRUCK TIRES, SIZE 10R22.5 LRG AND LRF FOR USE ON FREIGHTLINER SCHOOL AND TRANSIT BUSES. THESE TIRES WERE MANFACTURED BETWEEN MAY 23 AND OCTOBER 24, 2004, CAN EXPERIENCE RAPID AIR LOSS DUE TO AN IRREGULARITY OF THE INNER LINER.

Dec 15, 2004 – ON CERTAIN VEHICLES, THERE IS A DEFECT IN THE INTERAXLE DRIVELINE YOKES. THE BOLT HOLES LOCATED ON THE EARWORK OF THE MALE SHAFT YOKES WERE MANUFACTURED WITH AN OVERSIZED MINOR THREAD DIAMETER.

Sep 15, 2004 – ON CERTAIN TRUCKS EQUIPPED WITH LIQUID NATURAL GAS (LNG) STYLE TANKS, NEITHER THE PRIMARY NOR THE SECONDARY RELIEF VALVES HAVE OPENED TO RELIEVE TANK PRESSURE UNDER CERTAIN CONDITIONS. SPECIFICALLY, THE INTRODUCTION OF WATER INTO THE DISCHARGE SIDE OF BOTH OF THESE VALVES SIMULTANEOUSLY AND SUBSEQUENT FREEZING IN SERVICE CAN RENDER THE VALVES TEMPORARILY INOPERATIVE.

Aug 12, 2004 – ON CERTAIN TRUCKS, THE STEERING GEAR BOLTS MAY BECOME LOOSE.

Jun 07, 2004 – ON CERTAIN TRUCKS BUILT WITH 8,000 OR 6,000 POUND FRONT AXLES AND FOUR-PIECE SPINDLE NUT SETS, PREMATURE FRONT ,WHEEL BEARING WEAR MAY BE CAUSED BY INCONSISTENT BEARING ENDPLAY ADJUSTMENT.

May 04, 2004 – ON CERTAIN TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, THE TAPERED JOINT THAT ATTACHES THE SHIFTER TO THE TRANSMISSION MAY BECOME LOOSE MAKING IT DIFFICULT TO PUT THE TRANSMISSION INTO GEAR.

Jun 17, 2003 – ON CERTAIN TRUCK TRACTORS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.

Mar 21, 2003 – ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

Dec 17, 2002 – ON CERTAIN TRUCK-TRACTOR MODEL VEHICLES EQUIPPED WITH CONMET SIMPLEX STATIONARY OR SLIDING FIFTH-WHEEL, THE CLINCH PINS THAT RETAIN THE FIFTH-WHEEL PIVOT PINS MAY NOT BE FULLY INSTALLED.

Dec 13, 2002 – ON CERTAIN HEAVY TRUCKS, THE CAST OUTPUT YOKE ON THE MERCEDES-BENZ TRANSMISSIONS COULD FRACTURE ON VEHICLE WITH 1610 OR 16T SERIES DRIVELINES.