TIFFIN ALLEGRO Recalls

Oct 25, 2010 – TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO, ALLEGRO BUS, AND PHAETON RVS EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Dec 29, 2009 – TIFFIN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 ALLEGRO BUS MODELS WITH POWERGLIDE CHASSIS EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES P/NOS. 6562618, 6565118, 77025-001, 77025-002, 77025-501, 77050-004, SUPPLIED BY KONGSBERG AUTOMOTIVE. SOME ASSEMBLIES COULD CONTAIN A DRIVE PIN THAT IS BELOW SPECIFICATION AND MAY BECOME DISENGAGED FROM THE BRAKE ARM CAUSING SEPARATION OR LOOSENING OF THE PEDAL FROM THE REMAINDER OF THE ASSEMBLY.

Nov 17, 2009 – TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLE EQUIPPED WITH NORCOLD MODEL 1200LR AND 1200LRIM REFRIGERATORS, MANUFACTURED FROM DECEMBER 1, 2001, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Apr 16, 2009 – TIFFIN IS RECALLING 329 MY 2008-2009 ALLEGRO BUSES. THE REAR AXLE ABS MODULATING VALVE HAVE THE POTENTIAL TO BE WIRED INCORRECTLY. THE RIGHT AND LEFT MODULATOR VALVE HARNESS PIN COULD POSSIBLY BE REVERSED AT THE ABS ELECTRONIC CONTROL UNIT (ECU) CONNECTOR.

Apr 03, 2009 – NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Feb 27, 2009 – TIFFIN IS RECALLING 1,408 MY 2006-2009 ALLEGRO BUS, MY 2007-2009 PHAETON AND MY 2005-2009 ZEPHYR VEHICLES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTMAN HITCHES. CERTAIN TRAILER HITCHES MAY FRACTURE WHICH COULD RESULT IN THE LOSS OF THE TRAILER.

Feb 05, 2009 – TIFFIN IS RECALLING 23 MY 2009 ALLEGRO BUSES EQUIPPED WITH ARVINMERITOR AXLE ASSEMBLIES. THE WHEEL END STUDS MAY HAVE BEEN IMPROPERLY TEMPERED RENDERING THEM BRITTLE AND SUSCEPTIBLE TO FRACTURE. IF ONE WHEEL STUD FRACTURES, THE REMAINING WHEEL STUDS ARE REQUIRED TO CARRY MORE LOAD. IF LEFT IN THIS CONDITION, THE REMAINING WHEEL STUDS MAY ALSO FRACTURE EVEN IF THEY ARE PROPERLY MANUFACTURED.

Oct 07, 2008 – TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Aug 26, 2008 – TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Jun 17, 2008 – DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.