TIFFIN Recalls

Apr 03, 2009 – NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Feb 27, 2009 – TIFFIN IS RECALLING 1,408 MY 2006-2009 ALLEGRO BUS, MY 2007-2009 PHAETON AND MY 2005-2009 ZEPHYR VEHICLES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTMAN HITCHES. CERTAIN TRAILER HITCHES MAY FRACTURE WHICH COULD RESULT IN THE LOSS OF THE TRAILER.

Feb 05, 2009 – TIFFIN IS RECALLING 23 MY 2009 ALLEGRO BUSES EQUIPPED WITH ARVINMERITOR AXLE ASSEMBLIES. THE WHEEL END STUDS MAY HAVE BEEN IMPROPERLY TEMPERED RENDERING THEM BRITTLE AND SUSCEPTIBLE TO FRACTURE. IF ONE WHEEL STUD FRACTURES, THE REMAINING WHEEL STUDS ARE REQUIRED TO CARRY MORE LOAD. IF LEFT IN THIS CONDITION, THE REMAINING WHEEL STUDS MAY ALSO FRACTURE EVEN IF THEY ARE PROPERLY MANUFACTURED.

Oct 07, 2008 – TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Aug 26, 2008 – TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Aug 01, 2008 – TIFFIN IS RECALLING 271 MY 2007-2008 PHAETON CLASS A MOTOR HOMES EQUIPPED WITH FREIGHTLINER CHASSIS. THE AAC FRONT AXLE STEERING ARM BOLTS WITH A LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER- TIGHTENED.

Jun 17, 2008 – DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

Jan 25, 2008 – CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING.

Nov 05, 2007 – ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Aug 15, 2007 – ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.