VOLKSWAGEN Recalls

Aug 11, 2008 – K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

May 28, 2008 – VOLKSWAGEN IS RECALLING 4,079 MY 2008 PASSAT AND 2,500 MY 2009 TIGUAN PASSENGER VEHICLES EQUIPPED WITH 2.0T FSI ULEV II ENGINES. THESE VEHICLES HAVE AN ENGINE CONTROL MODULE (ECM) CONTAINING SOFTWARE THAT MAY NOT PROPERLY CONTROL ENGINE IDLE WITH THE AIR CONDITIONING TURNED ON. IN RARE CASES, THE ECM MAY UNEXPECTEDLY INCREASE ENGINE RPM.

Apr 17, 2008 – VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS.

Apr 07, 2008 – VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Jan 28, 2008 – ON CERTAIN PASSENGER VEHICLES, A FUEL SUPPLY LINE WAS CHANGED DURING PRODUCTION WHICH COULD LEAD TO INSUFFICIENT SEALING OF THE FUEL SUPPLY LINE CONNECTOR.

Jan 28, 2008 – ON CERTAIN SPECIAL EDITION TRIPLE WHITE SEDAN VEHICLES, AN INCORRECT ADHESIVE MAY HAVE BEEN USED TO ATTACH THE ROOF SPOILER TO THE REAR GLASS OF THE VEHICLE. IF THE INCORRECT ADHESIVE WAS USED, THE SPOILER COULD BECOME LOOSE OR FALL FROM THE VEHICLE WITHOUT WARNING, EVEN THOUGH INITIALLY THE SPOILER MAY FEEL SECURE.

Sep 24, 2007 – CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.

Aug 28, 2007 – ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.

Jun 25, 2007 – CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.

Jun 25, 2007 – CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE OWNER'S MANUAL IS MISSING THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WRITTEN INSTRUCTIONS.