AMERICAN MOTORS GREMLIN Recalls

Apr 30, 2009 – FEDERAL-MOGUL CORPORATION IS RECALLING 2,790 MECHANICAL FUEL PUMPS, P/NO. M6737 SOLD UNDER CARTER AND NAPA BRANDS AND P/NO. 2M6737 SOLD UNDER ACCU-FLOW AND TRU-FLOW BRANDS SHIPPED BETWEEN AUGUST 2008 AND MARCH 2009 FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM ROD IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY MANUFACTURED. IMPROPERLY MANUFACTURED PUMP DIAPHRAGM RODS MAY CAUSE THE PUMP TO PRODUCE EXCESS PRESSURE.

Aug 27, 2007 – CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.

Apr 04, 1978 – THE HIGH PRESSURE POWER STEERING HOSE MAY HAVE BEEN ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. AS A RESULT, THE HEAT FROM THE MANIFOLD COULD DAMAGE THE HOSE.

Mar 09, 1978 – THE ELECTRONIC IGNITION SYSTEM SENSOR CIRCUIT CONTAINS A TWO-WIRE CONNECTOR WHICH COULD CAUSE DIFFICULTY IN THE ENGINE IGNITION. THIS DIFFICULTY MAY BE CAUSED BY MECHANICAL OR CHEMICAL ACTIONS AT THE CONNECTOR.

Dec 20, 1977 – ON THE INVOLVED VEHICLES INTERFERENCE MAY EXIST BETWEEN THE INSTRUMENT PANEL WIRING HARNESS AND THE CLUTCH LINKAGE. AS A RESULT OF THIS INTERFERENCE, THE HARNESS MAY BECOME CHAFED BY THE CLUTCH LINKAGE DURING NORMAL CLUTCH OPERATION. THIS CONDITION COULD LEAD TO AN ELECTRICAL FIRE SHOULD AN ELECTRICAL SHORTAGE OCCUR.

May 09, 1977 – ON THE INVOLVED VEHICLES, THE ACCELERATOR CABLE MAY HAVE AN OVERLY LONG PLASTIC SLEEVE AT ITS CARBURETOR END. THIS COULD ALLOW THE SLEEVE TO BECOME STUCK IN THE END-FITTING WHEN THE ACCELERATOR PEDAL IS PRESSED TO THE FLOOR. THIS WOULD CAUSE THE THROTTLE TO STICK IN THE OPEN POSITION.