BMW Recalls

Aug 05, 2008 – BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.

Jul 25, 2008 – BMW IS RECALLING 428 MY 2007 F800 S, F800 ST, R1200 R, K1200 S, K1200 R, K1200 R SPORT, AND K1200 GT MOTORCYCLES. IT IS POSSIBLE FOR THE COATING TO SEPARATE FROM THE INSIDE FACE OF THE STEERING DAMPER HOUSING. IF THIS HAPPENED, THE COATING COULD PARTIALLY CLOG THE OIL BORES WITHIN THE DAMPER.

Jul 01, 2008 – BMW IS RECALLING 46 MY 2008 R1200 R, R1200 GS, AND R1200 GS ADVENTURE MOTORCYCLES. DUE TO A MATERIAL DEFECT IN THE INTERMEDIATE SHAFT OF THE TRANSMISSION, THE SHAFT COULD BREAK. IF THIS OCCURRED, IT IS POSSIBLE FOR THE TRANSMISSION TO SEIZE.

Jun 05, 2008 – BMW IS RECALLING 4,922 MY 2007-2008 R1200R, MY 2006-2007 R1200 GS, MY 2007 R1200 ST, AND MY 2008 R1200 GS ADVENTURE MOTORCYCLES. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINES COULD SPLIT AND START TO DEVELOP A LEAK. IF THE LEAK BECAME SIGNIFICANT, BRAKE FLUID COULD ESCAPE. IF THIS HAPPENED, THE LEVEL OF FLUID IN THE RESERVOIR OF THE FRONT BRAKE SYSTEM COULD DROP.

Jun 04, 2008 – BMW IS RECALLING 548 MY 2008 K1200 S AND GT MOTORCYCLES. THE FASTENERS USED TO SECURE THE FRONT BRAKE-DISC MAY NOT BE LONG ENOUGH TO ENSURE A SECURE MOUNTING. OVER TIME, THESE FASTENERS COULD LOOSEN. IF THAT HAPPENED, THE BRAKE DISC WOULD NO LONGER BE SECURELY MOUNTED.

Jun 02, 2008 – BMW IS RECALLING 30 MY 2008 K1200 S AND K1200 GT MOTORCYCLES. A SET SCREW MAY NOT HAVE BEEN INSTALLED AT ITS SPECIFIC LOCATION WITHIN THE OIL DUCT. CONSEQUENTLY, AN ADEQUATE SUPPLY OF OIL MAY NOT CIRCULATE WITHIN THE ENGINE.

Jun 02, 2008 – BMW IS RECALLING 1,980 MY 2007-2008 F800 S AND F800 ST MOTORCYCLES. DUE TO THE ROUTING OF THE FUEL TANK BREATHER HOSE, PRESSURE EQUALIZATION INSIDE THE FUEL TANK IS POSSIBLE ONLY TO A LIMITED EXTENT. CONSEQUENTLY, AT HIGH AMBIENT TEMPERATURES, THE FUEL TANK CAN DEFORM. IF THIS HAPPENED AT THE POINT WHERE THE FUEL TANK IS SHAPED TO PROVIDE CLEARANCE FOR THE REAR WHEEL, THEN, IN COMBINATION WITH A LARGE PAYLOAD, THE BOTTOM OF THE TANK COULD RUB AGAINST THE REAR WHEEL.

Apr 11, 2008 – BMW IS RECALLING 55 MY 2008 X5 SPORT UTILITY VEHICLES FOR PROBLEMS WITH THE REAR AXLE STABILIZER (ANTI-SWAY BAR). THESE VEHICLES WERE EQUIPPED WITH A SPORTS-SUSPENSION STABILIZER RATHER THAN A STANDARD SUSPENSION STABILIZER ON THE REAR AXLE.

Mar 11, 2008 – BMW IS RECALLING 1,391 MY 2007 G650X CHALLENGE, COUNTRY, AND MOTO MOTORCYCLES. THE FUEL LINES MAY HAVE BEEN DAMAGED DURING PRODUCTION, AND COULD DEVELOP A LEAK. THE LEAK COULD OCCUR EITHER THROUGH THE FABRIC INLAY AT THE END OF THE LINE, OR, THROUGH A CRACK IN THE ACTUAL LINE.

Mar 11, 2008 – BMW IS RECALLING 744 MY 2007 G650X CHALLENGER AND COUNTRY MOTORCYCLES. THE MOTORCYCLES MAY HAVE HAD THE WRONG CIRCULAR CLIP INSTALLED ON THE LEFT HAND SIDE OF THE REAR WHEEL BEARING GUIDE. THIS CIRCLIP CAN RUB AGAINST A SPACER BUSHING, CREATING METAL SHAVINGS WHICH MAY ENTER THE WHEEL BEARING, CAUSING IT TO FAIL AND THE ANTILOCK BRAKE SYSTEM (ABS) MAY MALFUNCTION. THIS WOULD BE INDICATED BY ILLUMINATION OF THE ABS WARNING LAMP.