FORD MUSTANG Recalls

Dec 21, 2001 – THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995 TAURUS/SABLE PASSENGER VEHICLES EQUIPPED WITH 3.0L AND 3.8L ENGINES AND 1995 FORD MUSTANG VEHICLES WITH 3.8L AND 5.0L ENGINES. IT IS POSSIBLE FOR THE ENGINE COOLING FAN BEARING TO SEIZE.

Oct 03, 2001 – EQUIPMENT DESCRIPTION: PASSENGER VEHICLES THAT HAVE HAD THE DRIVER'S AIR BAG MODULE REPLACED AFTER APRIL 5, 2000. THE REPLACEMENT DRIVER'S AIR BAG MODULE INFLATOR MAY HAVE INSUFFICIENT WELDS THAT COULD PREVENT PROPER INFLATION OF THE AIR BAG.

Apr 11, 2001 – VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE BALL JOINT ASSEMBLY IN THE REAR KNUCKLE, WHERE THE LOWER CONTROL ARM ATTACHES, IS DISPLACED LONGITUDINALLY FROM ITS INSTALLED POSITION, IT CAN CAUSE HIGHER STRESS LEVELS IN THE KNUCKLE CASTING. IF THIS OCCURS, THE CASTING COULD FRACTURE, ALLOWING THE CORNER OF THE VEHICLE TO DROP, AND THE LOWER CONTROL ARM COULD CONTACT THE INSIDE OF THE REAR WHEEL.

Nov 03, 2000 – VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4.6L ENGINES. A COOLANT FLOW BLOCKAGE EXISTS AT THE INTAKE MANIFOLD HEATER CORE NIPPLE RESULTING IN NO COOLANT FLOW TO THE HEATER AND, THEREFORE, NO WARM AIR FLOW FROM THE HEATER OR WINDSHIELD DEFROSTER. VEHICLES WITH THIS CONDITION DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS."

Oct 30, 2000 – VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. IF A VEHICLE IS PARKED WITH THE PARKING BRAKE NOT FULLY APPLIED AND NOT IN FIRST GEAR, AS DIRECTED IN THE OWNER GUIDE, AND THE SELF ADJUSTMENT PAWL SUBSEQUENTLY SKIPS ONE OR TWO TEETH, THE VEHICLE COULD MOVE ON SOME GRADES.

Sep 20, 1999 – VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.

Mar 30, 1999 – VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Nov 24, 1997 – VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4.6L ENGINES. SOME OF THESE VEHICLES HAS MISSING OR INADEQUATE BRAZE JOINTS BETWEEN THE FUEL RAIL BODY AND THE FUEL RAIL MOUNTING BRACKET(S).

Oct 20, 1997 – VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS. TEARING OF THE BOND BETWEEN THE INNER AND OUTER HOOD PANELS DURING MINOR FRONT END COLLISIONS CAN RESULT IN A GAP AT THE LEADING EDGE OF THE HOOD. AIR FORCED BETWEEN THE INNER AND OUTER PANELS CAN PRODUCE ENOUGH PRESSURE TO FORCE THE OUTER PANEL UPWARD.

Sep 30, 1997 – VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI-VANS. THE RACK AND PINION STEERING GEARS MAY HAVE DAMAGED INPUT SHAFT BEARINGS.