STERLING Recalls

Jul 27, 2010 – DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FREIGHTLINER, FCCC, STERLING, AND WESTERN STAR HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.

Jul 13, 2010 – DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 FREIGHTLINER BUSINESS CLASS M2, STERLING ACTERRA, A-LINE, AND L-LINE HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 8, 2008 THROUGH APRIL 20, 2009 EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)

Jun 08, 2010 – DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008-2009 STERLING 360 VEHICLES MANUFACTURED FROM AUGUST 8, 2007 THROUGH JULY 31, 2008. THE GROUND HARNESS CONNECTOR FOR THE ABS HYDRAULIC UNIT MAY BECOME CORRODED DUE INTRUSION POTENTIALLY CAUSING THE ABS HYDRAULIC MOTOR TO RUN CONTINUOUSLY.

Mar 23, 2010 – DAIMLER TRUCKS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2010 FREIGHTLINER COLUMBIA, FLD, STERLING 9500 AND WESTERN STAR 4900 EMERGENCY VEHICLES. THE ENGINE MAY SHUT DOWN UNEXPECTEDLY WHEN A DIESEL PARTICULATE FILTER OVER TEMPERATURE CONDITION IS DETECTED.

Nov 24, 2009 – DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 FREIGHTLINER M2, CUSTOM CHASSIS MT55, AND STERLING ACTERRA VEHICLES MANUFACTURED BETWEEN APRIL 4, 2007 AND JULY 15, 2009, EQUIPPED WITH CUMMINS ISC CM2150 AND ISL CM2150 MODEL DIESEL ENGINES. THE VEHICLES MAY BE DESIGNED WITH A HARD WIRED, DASH-MOUNTED SWITCH THAT ENABLES THE VEHICLE OPERATOR TO INHIBIT AFTERTREATMENT DIESEL PARTICULATE FILTER REGENERATION IN ENVIRONMENTS WHERE THE OPERATOR BELIEVES IT MAY BE UNSAFE FOR ELEVATED EXHAUST TEMPERATURES. DUE TO AN ISSUE WITH THE LOGIC IN THE ECM SOFTWARE IN THESE ENGINES, THE SWITCH MAY NOT FUNCTION CORRECTLY, LEADING THE OPERATOR TO BELIEVE THAT THE SWITCH IS IN "INHIBIT" MODE WHEN IT IS NOT.

Nov 24, 2009 – DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 STERLING 360 VEHICLES. THE WEATHER RESISTANCE PROPERTIES OF THE AIR INTAKE DUCT RUBBER CUSHIONS IS INSUFFICIENT. DURING NORMAL VEHICLE OPERATION, THE RUBBER CUSHIONS DETERIORATE AND CRACK.

Nov 19, 2009 – CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Nov 02, 2009 – DAIMLER TRUCKS IS RECALLING MODEL YEAR 2009-2010 FREIGHTLINER, AND STERLING VEHICLES EQUIPPED DETROIT DIESEL DD13 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GRID HEATER CIRCUIT BOARD LEADING TO A SHORT CIRCUIT.

Oct 08, 2009 – DAIMLER TRUCKS IS RECALLING MODEL YEAR 2007-2010 FREIGHTLINER, STERLING AND WESTERN STAR VEHICLES EQUIPPED WITH DETROIT DIESEL DD15 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GRID HEATER CIRCUIT BOARD LEADING TO A SHORT CIRCUIT.

Oct 06, 2009 – DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 HEAVY TRUCKS MANUFACTURED BETWEEN MAY 5, 2008 AND JANUARY 7, 2009, EQUIPPED DD15 ENGINES AND WITH BOSCH HIGH PRESSURE FUEL PUMPS. THE FASTENERS ON THESE FUEL PUMPS COULD BE UNDER-TORQUED ALLOWING THE "O" RING BETWEEN THE PUMP HOUSING AND THE BARREL TO PROTRUDE AND LEAK.