VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LEFT FRONT UPPER CONTROL ARM MAY NOT MEET THE SPECIFIED

Sep 10, 2001 — Recall Campaign #01V290000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LEFT FRONT UPPER CONTROL ARM MAY NOT MEET THE SPECIFIED STRENGTH REQUIREMENTS.

The recall was influenced by the manufacturer with about 870 units affected.

See recall notice

NHTSA Safety Recall Notice

01V290000

Manufacturer:	Mercedes-Benz USA, LLC
Recall date:	September 10, 2001
NHTSA Campaign #:	01V290000
Units affected:	870

Description:: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LEFT FRONT UPPER CONTROL ARM MAY NOT MEET THE SPECIFIED STRENGTH REQUIREMENTS.
Consequeces:: THE CONTROL ARM COULD FAIL, INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL REPLACE THE LEFT FRONT UPPER CONTROL ARM. OWNER NOTIFICATION BEGAN SEPTEMBER 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERCEDES-BENZ AT 1-800-367-6372.
Notes:: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2002 MERCEDES BENZ ML320 Complaints
The contact owns a 2002 Mercedes-Benz ML320. The contact stated while driving at approximately 25 MPH, the driver’s side front wheel independently braked. The contact stated he had not depressed the brake pedal but heard an abnormal sound from the tire screeching as the wheel had stopped rolling. The contact stated that the ESP traction warning light was illuminated. The contact pulled the vehicle over, turned off, restarted the vehicle, and was able to continue driving. The contact stated that the failure occurred several minutes later. The contact stated that the failure occurred one other time and had not happened again. The contact had not taken the vehicle to a local dealer or independent. The vehicle had not been diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 198,000.;
2002 MERCEDES BENZ ML500 Complaints
There is a serious defect in the YAW rate sensors in these Mercedes ML W163's. Thank God I was driving down a secluded road and nobody was behind me, but my vehicles brakes locked up, on their own, even with my foot on the accelerator pedal, with no warning lights or warning signals. I have no error codes, and my vehicle is well maintained. There are many many people that are having the same issue with their Mercedes ML's. Some people have experienced this happening to them at freeway speeds. The YAW rate sensors are at fault, and send a signal to the ABS pump which in turn locks up the brakes without even touching the brake pedal! This is EXTREMELY DANGEROUS to everyone in the vehicle, and to ANY other vehicle in the area. People can DIE! Again.. This is a terrible defective function of a sensor that will spontaneously apply the brakes fully to lock up automatically with no persuasion from the driver. It is extremely dangerous and can cause fatal injuries. This has been researched thru many Mercedes forums including benzworld.org, mbworld.org, Mercedesforum.com, and ml w163 Facebook forum, all of which many ML owners have experienced the braking system lockup, and in some cases accidents have occurred. Another unfortunate issue in this happening, is that the brake lights do not light up when this sudden braking happens due to the YAW rate sensor malfunction. If there is a vehicle behind a Mercedes ML when this sudden braking occurs, there is NO WARNING LIGHTS, and can cause a serious accident and injury or death! Many people, including myself, do not feel safe behind the wheel of our Mercedes ML's for fear of the brakes locking up in their own because of this poorly programmed default function of a possible faulty YAW rate sensor. This is the worst default function to ever have a vehicle do. I now steer clear of other Mercedes ML's in the road knowing they can automatically lock their brakes for no apparent reason. Please research this and take action!;
2002 MERCEDES BENZ ML55 Complaints
WHILE DRIVING 40 MPH MY ABS LIGHT SHOWN UP AND ALL 4 TIRES LOCK UP. ALMOST CAUSE AN ACCIDENT. *TR;