2002 MERCEDES-BENZ ML320 Complaints

The contact owns a 2002 Mercedes-Benz ML320. The contact stated while driving at approximately 25 MPH, the driver’s side front wheel independently braked. The contact stated he had not depressed the brake pedal but heard an abnormal sound from the tire screeching as the wheel had stopped rolling. The contact stated that the ESP traction warning light was illuminated. The contact pulled the vehicle over, turned off, restarted the vehicle, and was able to continue driving. The contact stated that the failure occurred several minutes later. The contact stated that the failure occurred one other time and had not happened again. The contact had not taken the vehicle to a local dealer or independent. The vehicle had not been diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 198,000.

The car brakes suddenly by itself just after the ESB/ABS lights come on along with an exclamation point (!). This has happened randomly at least 4 times since we purchased the car. Once at high speeds on the highway. It appears this problem is common with other owners of Mercedes 2001-2002 ML's. According to the forums below, the problem seems to be a "YAW RATE SENSOR" malfunction or defect. My Mercedes mechanic saw no error codes for this component and it seem extremely expensive (forum states part is $3000) to replace. The https://mbworld.org/forums/m-class-w163/233486-big-problems-ml320-pls-help-2.html

FUSE BOX SOME HAS POWER SOME NOT. FRONT LEFT WHEEL MAKING THIS NOISE AND STOPS AFTER 25 MILES PER HOUR RADIO VOLUME LOW WHEN IGNITION KEY IS ON POSITION 3 WHEN KEY IT'S IN THE POSITION 2 LAUD VOLUME WHEN KEY IS NOT IN I CAN TURN ON THE STEREO

YES THIS [XXX] COMING TO YOU TO LET YOU KNOW THAT I WAS AND A CAR ACCIDENT I WAS STRUCK BY AND VEHICLE MADE BY OLDSMOBILE YEAR 1998 PLATE NO. STATE [XXX] I WAS ON MY WAY HOME FROM DOWN TOWN FEDERAL COURT I WAS RIDING DOWN [XXX] CRASH DATE 08/21/2018. I WAS AT THE RED LIGHT I ALSO HAD MY HAZARD LIGHTS ON ALSO NOW I WAS SITTING AT THE RED LIGHT WAITING FOR THE TRAFFIC LIGHT TO TURN GREEN NEXT THING I KNOW THE SENIOR CITIZEN THE GUY WHO HIT ME FROM BEHIND. NEXT THING I KNOW MY 2002 ML320 MERCEDES BENZ DID A WHOLE 360 DEGREE SPIN AROUND I DIDN'T PANIC I WAS JUST AND TOTAL SHOCK I GOT OUT THE CAR AND WALK TO THE CAR TO CHECK IN SEE WAS THE PERSON OKAY OR NOT BECAUSE I DIDN'T KNOW WHO WAS DRIVING THE CAR WHEN I LOOK IN REALIZE IT WAS A SENIOR CITIZEN I ASK HIM ARE YOU OKAY HE SAID YES BUT HE WAS KIND OF DAZE I NOTICE THE CAR WAS LEAKING REAL BAD SO I STOOD ALL THE WAY BACK FOR MY SAFETY REASON BECAUSE THE PERSON WHO HIT ME WHICH IS THE SENIOR CITIZEN STARED TO SMOKE SO I STOOD ALL THE WAY BACK CAUSE I THOUGHT THE CAR WAS GO BLOW UP BUT I THANK GOD IT DIDN'T. SO THE AMBULANCE ARRIVE ON THE CAR ACCIDENT. THEY TOOK THE PERSON WHO HIT ME TO THE HOSPITAL. WHICH HE LIVED THEN ALL THE POLICE FORCES CAME I MEAN EVERY TOP LAW CAME PACE BY PACE TO MAKE SURE EVERYTHING WAS OKAY. LONG STORY SHORT. MY CAR WAS INVOLVE IN A CAR ACCIDENT OH YEAR I HAD MY SEAT BELT ON TOO SAFETY FIRST. GOD BLESS YOU ALL ALWAYS BUCKLE UP AND CHECK ALL YOU MIRROR. HAVE A NICE DAY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

"TAKATS RECALL" 1ST ISSUE I NOTICED IS WHEN I GAVE SOMEONE A JUMP OFF A DEAD CAR BATTERY. AS I WAS DRIVEN I NOTICED MY CAR BATTERY LIGHT CAME ON MEANING MY BATTERY WAS DECREASING POWER AND IT DID I WAS ON MY WAY HOME DRIVEN I NOTICED MY CAR LOSING POWER IN THE CAR SHUT COMPLETELY OFF SO I PULLED TO THE SIDE AND I CALLED SOMEONE TO GIVE ME A JUMP THE CAR STARTED BACK UP DROVE ABOUT 3, BLOCKS AND THE CAR SHUT COMPLETELY OFF AGAIN SO I PURCHASED A BRAND NEW BATTERY REPLACING THE OLD BATTERY WITH AN NEW ONE. GOT ANOTHER JUMP TO GIVE THE THE BATTERY SOME EXTRA JUICE. AFTER I RECEIVED THE JUMP I'M BACK ON THE ROAD. IN THE ANCIENT OCCUR AGAIN SO I CALLED SOMEONE TO GIVE ME A JUMP. THIS TIME THE CAR DIDN'T START. SO I HAD TO GET IT TOW HOME. GOT HOME DID SOME RESEARCH IN FOUND OUT IT WAS THE ALTERNATOR. REPLACE THE OLD ALTERNATOR WITH A NEW ONE. 2ND ISSUE I NOTICED AFTER I REPLACED THE OLD ALTERNATOR WITH THE NEW ONE I NOTICED MY TWO FANS BLOWER WILL CONTINUOUSLY RUN FOR HOURS WHEN I TAKE MY CAR KEYS OUT OF THE IGNITION. AND DUE TO THAT THAT CAUSE MY DRAINED MY BATTERY CAUSING ME TO LOSE POWER AND MY CAR WON'T BE ABLE TO START WHEN I PUT MY KEY IN THE IGNITION I DON'T KNO IF THEY CONNECTED A WIRE TO KEEP RUNNING IF SO HE WAS TO SUPPOSED TO TELL ME THAT WHICH HE DIDN'T. 3RD ISSUE I NOTICED I RECENTLY ADDED NEW FRONT PADS AND ROTOR'S NEW REAR PADS AND ROTORS 1 NEW REAR PASSSGER SIDE BRAKE CALIPER. MY BRAKE LIGHTS STILL APPEARED TO POP UP I TOLD THE MERCHANT HE TOLD ME IT COULD BE A SENSOR FAILURE AND GET CHECK OUT AT A MERCEDES BENZ DEALER. 4TH ISSUE THE TRIANGLE LIGHT LOCATED IN THE CENTER OF DASH FLASHES OCCASIONALLY CAUSING UNDER CERTAIN CIRCUMSTANCES, TAPPING THE BRAKE PEDAL MAY NOT AUTOMATICALLY DISENGAGE CRUISE CONTROL AS EXPECTED IN CERTAIN MODEL YEAR RECALL SUBJECT: SUSPENSION: FRONT CONTROL ARM UPPER ARM .RECALL: 6/SERVICE BULLETINS: 2

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ ML320. THE CONTACT STATED THAT THE AIR CONDITIONER FAILED TO TURN OFF WHEN THE ENGINE WAS TURNED OFF. THE CONTACT ALSO STATED THAT THE VEHICLE WAS DIFFICULT TO START. THE CONTACT PURCHASED AND INSTALLED A NEW ALTERNATOR; HOWEVER, THE VEHICLE FAILED TO START. THE BATTERY WAS ALSO REPLACED, BUT THE ENGINE STILL TOOK SEVERAL ATTEMPTS TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT SCHEDULED AN APPOINTMENT WITH PRIME TIME NISSAN OF SCHERERVILLE (1301 INDIANAPOLIS BLVD, SCHERERVILLE, IN 46375) FOR DIAGNOSTIC TESTING AND REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.

I WAS DRIVING ON A BUSY INTERSECTION IN MY 2002 MERCEDES BENZ ML320 WHEN DRIVING THE YELLOW TRIANGLE IN THE SPEEDOMETER STARTS TO FLASH AND ALL THE BREAKS LOCK UP, THIS IS FOLLOWED BY A STALL, THANKFULLY I WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD WITHOUT BEING HIT. AFTER DOING SOME RESEARCH I DISCOVERED THAT MANY MERCEDES ML320 OWNERS WERE HAVING THIS SAME PROBLEM. SPECIFICALLY THE YAW RATE SENSOR. THIS IS A SERIOUS LIFE THREATENING ISSUE THAT CAN INJURE OR WORSE YET KILL SOMEONE. YOU GUYS NEED TO DO A RECALL BEFORE SOMEONE DIES!

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ ML320. THE CONTACT STATED THAT THE BAS AND ESP WARNING INDICATORS ILLUMINATED. IN ADDITION, THE CONTACT EXPERIENCED EXTREME DIFFICULTY TURNING LEFT AND RIGHT AND HAD TO RESTART THE VEHICLE SEVERAL TIMES DUE TO THE FAILURES. THE UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS ALSO NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

I WAS PULLING AWAY FROM THE CURB, STEERING WHEEL STARTED MAKING WHINING NOISES AND HARDER TO TURN. I CONTINUED ON CITY STREETS THEN TO A FREEWAY WHERE MY CAR BEGAN TO OVERHEAT. I PULLED OVER AT A GAS STATION OPENED THE HOOD AND COULD SEE FLUID ALL OVER RIGHT LOWER DRIVER SIDE. IT SEEMED TO BE COMING FROM A HOSE BY THE POWER STEERING CAP AND THE RIGHT SIDE OF THE RADIATOR. UNDER THE CAR SAME SPOT RIGHT PASSENGER SIDE I COULD SEE POWER STEERING AND RADIATOR COOLANT LEAKING FROM THAT AREA.

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ ML320. THE CONTACT STATED THAT THE VEHICLE WAS RIDING EXTREMELY ROUGH AND FAILED TO ACCELERATE. THE VEHICLE WAS DIAGNOSED BY TWO INDEPENDENT MECHANICS WHO STATED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. IN ADDITION, THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT THE PART WAS NO LONGER IN PRODUCTION AND THAT THE CONTACT MAY REPLACE THE PART WITH AN AFTERMARKET CATALYTIC CONVERTER; HOWEVER, THE VEHICLE MAY NOT PASS AN EMISSIONS INSPECTION. THE CATALYTIC CONVERTER FAILED ON THE FRONT PASSENGER SIDE AND THE CONTACT WAS UNCERTAIN OF WHO WOULD BE ABLE TO REPLACE THE PART WITH AN OEM CATALYTIC CONVERTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS WAITING FOR THEM TO DETERMINE A SOLUTION TO REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.