VEHICLE DESCRIPTION: MOTOR HOME AND COMMERCIAL CHASSIS. THE REAR AXLE U-BOLTS MAY NOT BE TIGHTENED

Oct 04, 2001 — Recall Campaign #01V317000

VEHICLE DESCRIPTION: MOTOR HOME AND COMMERCIAL CHASSIS. THE REAR AXLE U-BOLTS MAY NOT BE TIGHTENED CORRECTLY DUE TO RANDOM FAILURE OF PRODUCTION TOOLING IN THE SPECIFIED TIME SPAN.

The recall was influenced by the manufacturer with about 5,011 units affected.

See recall notice

NHTSA Safety Recall Notice

01V317000

Manufacturer:	WORKHORSE CUSTOM CHASSIS
Recall date:	October 04, 2001
NHTSA Campaign #:	01V317000
Units affected:	5,011

Description:: VEHICLE DESCRIPTION: MOTOR HOME AND COMMERCIAL CHASSIS. THE REAR AXLE U-BOLTS MAY NOT BE TIGHTENED CORRECTLY DUE TO RANDOM FAILURE OF PRODUCTION TOOLING IN THE SPECIFIED TIME SPAN.
Consequeces:: LOW U-BOLT TORQUE CAN RESULT IN U-BOLTS COMING LOOSE AND NOT PROPERLY RETAINING THE REAR AXLE TO THE VEHICLE, RESULTING IN A LOSS OF VEHICLE CONTROL.
Corrective action:: DEALERS WILL TIGHTEN THE REAR AXLE U-BOLTS. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WORKHORSE AT 1-877-946-7731.
Notes:: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2001 WORKHORSE P320032 Complaints
VEHICLE STOPPED DEAD NO ELECTRICAL SMOKE CAME FROM UNDER DASH. WOULD NO START AFTER THAT. *TR;
2001 WORKHORSE P320042 Complaints
THE PARK-BRAKE AND PARK HAS FAILED TWICE ON MY 2001 MOTOR HOME ON A WORKHORSE CHASSIS. THE FIRST TIME UNDER WARRANTY AT 25,784 MILES AND THE SECOND AT 43,634. THE VEHICLE FREELY ROLLS WHEN THIS HAPPENS. THERE IS NO WAY TO STOP IT FROM ROLLING EXCEPT TO BLOCK THE TIRES. THIS MH HAS A GVW OF 18,000 POUNDS. VERY DANGEROUS WHEN ROLLING FREELY. *TR;
2001 WORKHORSE W20 Complaints
TL* THE CONTACT OWNS A 2001 WINNEBAGO. THE CONTACT SMELLED SOMETHING BURNING, AND STATED THAT THE BRAKES WERE DRAGGING. THE MANUFACTURER REPLACED THE BRAKE PADS, ROTORS, AND ABS. THE CONTACT LATER RECEIVED A RECALL FOR THE BRAKES. THE MANUFACTURER INSTALLED A BRAKE REPAIR KIT ON 11/4/04, BUT THE VEHICLE BEGAN TO EXPERIENCE THE SAME BRAKE FAILURE AND BURNING SMELL. THE CONTACT HAS THE REPAIR INVOICE FROM THE RECALL. THE FAILURE MILEAGE WAS 41000. *AK UPDATE 4/19/2007 *TR;
2001 WORKHORSE W22 Complaints
TL* THE CONTACT OWNS A 2001 MONACO MONARCH EQUIPPED WITH A WORKHORSE W22 CHASSIS. THE CONTACT WAS DRIVING APPROXIMATELY 58 MPH AND APPLIED THE BRAKES, WHICH BEGAN TO PULSATE ABNORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FRONT BRAKE PADS, CALIPERS AND BOTH FRONT ROTORS WERE REPLACED. THE REPAIRS WERE MADE THREE SEPARATE TIMES. THE FAILURE PERSISTED AFTER EACH REPAIR WAS PERFORMED. THE CONTACT PLANNED TO REPLACE THE PASSENGER'S SIDE ROTOR HIMSELF. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 5,000.;