CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS

Feb 04, 2004 — Recall Campaign #04V045000

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

The recall was influenced by the manufacturer with about 68,875 units affected.

See recall notice

NHTSA Safety Recall Notice

04V045000

Manufacturer:	General Motors, LLC
Recall date:	February 04, 2004
NHTSA Campaign #:	04V045000
Units affected:	68,875

Description:: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequeces:: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective action:: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:: GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2004 CADILLAC ESCALADE Complaints
When this device is used to replace the Flasher Module (my had failed so I ordered this replacement from Amazon) I found that the brake light circuit to any trailer connected tot he vehicle would no longer work. Under further research on Amazon via reviews and other online sources, I found that all of the Chinese clone parts have this same failure mode. Since most people check trailer lights with Directionals or 4 Way flashers, they would not be aware of the failure of the brake (stop) lamps not working on the trailer leading to critical dangerous situation if they need to slow as the driver behind them is likely to rear end the trailer due to the failure of the stop lamps to light.;
2004 CADILLAC ESCALADE ESV Complaints
The contact owns a 2004 Cadillac Escalade ESV. The contact stated that the ABS and traction stability warning lights were illuminated. The vehicle was taken to a local dealer and was diagnosed with needing the shocks and struts replaced. The vehicle was repaired but continued to experience the failure. The manufacturer was informed of the failure and was awaiting a response. The failure mileage was approximately 100,000.;
2004 CADILLAC ESCALADE EXT 1500 Complaints
TRUCK STALLS OUT WHEN PULLING OUT. NO MATTER HOW MUCH YOU PUSH ON THE GAS PEDAL. GETTING SERVICE STABILITY TRAK CONTROL MESSAGES, WHEN TURNING IT OFF IT SEEMS IT DOES NOT STALL OUT AS BAD. GAS GAUGE IS STICKING, NEVER KNOW HOW MUCH GAS YOU TRULY HAVE EVERYDAY!!;
2004 CHEVROLET AVALANCHE 1500 Complaints
The brake pressure modulator valve leaks the transmission has problems and service airbags is on;
2004 CHEVROLET EXPRESS Complaints
NHTSA Campaign Number: 12V388000. I have this problem. A leaking fuel line due to corrosion. I drive in the Cascade MT's of Washington state. my line now leaks excessively on fill up.;