ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES

Mar 16, 2004 — Recall Campaign #04V128000

ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.

The recall was influenced by the manufacturer with about 127,580 units affected.

See recall notice

NHTSA Safety Recall Notice

04V128000

Manufacturer:	Subaru of America, Inc.
Recall date:	March 16, 2004
NHTSA Campaign #:	04V128000
Units affected:	127,580

Description:: ON CERTAIN PASSENGER SEDANS, WAGONS, AND SPORT UTILITY VEHICLES, THE CRUISE CONTROL CABLE COULD COME OUT OF ITS TRACK ON THE CRUISE CONTROL LEVER AND LODGE ON THE CONTROL LEVER TAB WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS CONDITION OCCURS, THE THROTTLE WILL NOT RETURN TO THE IDLE POSITION AND WILL REMAIN IN AN OPEN POSITION.
Consequeces:: IF THIS OCCURS DURING VEHICLE OPERATION, THE DRIVER COULD LOSE CONTROL OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Corrective action:: DEALERS WILL INSTALL A CRUISE CONTROL CABLE RETAINING CLIP TO THE CRUISE CONTROL LEVER TAB ON THE THROTTLE SHAFT IN ORDER TO PREVENT THE CRUISE CONTROL CABLE FROM COMING OUT OF ITS TRACK. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT SUBARU AT 1-800-782-2783.
Notes:: SUBARU RECALL NO. WWQ-01.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2004 SUBARU IMPREZA Complaints
The contact owns a 2004 Subaru Impreza. The contact stated while driving 60 MPH and hard braking, the vehicle started shuddering violently and the steering wheel was not operating as needed. The contact was able to drive the vehicle to the residence at 20 MPH. The contact then inspected the vehicle and confirmed that the front driver's side control arm had fractured. The contact related the failure to NHTSA Campaign Number: 11V464000 (Suspension). The dealer and the manufacturer were notified of the failure and confirmed that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The failure mileage was approximately 235,000.;
2004 SUBARU LEGACY Complaints
AT 26,469 miles the harmonic balancer separated into two pieces while driving causing sudden loss of power steering. I contacted Subaru for assistance with this know problem. They refused a free repair. I have been a Master ASE mechanic for over 25 years at a dealership and know repairs of this type are usually done in house under a goodwill policy, otherwise swept under the rug so there is no recall. I went to the local dealer here and the tech there said he use to do the repair almost everyday. the same thing happened to my housemates at some time and he doesn't remember the details. This is a serious problem and there should be a recall as it could result in death given the circumstances the driver is driving in.;
2004 SUBARU OUTBACK Complaints
AUTOZONE SOLD ME (VIA WARRANTY EXCHANGE) AFTERMARKET BRAKE PADS THAT SUPPOSEDLY WERE THE SAME PART #D929 AS THE BRAKE PADS AUTOZONE HAD PREVIOUSLY SOLD ME AND WAS REPLACING UNDER WARRANTY. HOWEVER, THE BRAKE PADS THAT THEY PROVIDED TO ME TODAY AS WARRANTY REPLACEMENTS WERE TOO LARGE FOR THE BRAKE CALIPER AND WOULD BE UNSAFE IF INSTALLED AND FORCED TO FIT IN THE CALIPER. SPECIFICALLY, THE INNER SHOULDER DIMENSION ON THESE PADS IS TOO LARGE TO FIT PROPERLY IN THE CALIPER. I VERIFIED THE PROBLEM BY PURCHASING BRAKE PADS FROM A DIFFERENT AUTO SUPPLY STORE AND INSTALLING THEM WITH NO DIFFICULTY. THIS PROBLEM OCCURRED WHEN THE VEHICLE WAS STATIONARY, BECAUSE IT HAPPENED DURING BRAKE PAD REPLACEMENT.;