2004 SUBARU IMPREZA Complaints

The contact owns a 2004 Subaru Impreza. The contact stated while driving 60 MPH and hard braking, the vehicle started shuddering violently and the steering wheel was not operating as needed. The contact was able to drive the vehicle to the residence at 20 MPH. The contact then inspected the vehicle and confirmed that the front driver's side control arm had fractured. The contact related the failure to NHTSA Campaign Number: 11V464000 (Suspension). The dealer and the manufacturer were notified of the failure and confirmed that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The failure mileage was approximately 235,000.

I have had this airbag recall repaired 8 years ago, yet the dealership (Autonation Subaru Arapahoe 9955 E Arapahoe Rd Centennial, CO 80112) REFUSES to submit the paperwork to complete the recall. I have contacted the dealership numerous times, I have had Subaru of America representatives come out to my house to verify this airbag recall has been completed, yet I cannot get the recall status of my vehicle to be updated to show that the recall has been completed.

The contact owns a 2004 Subaru Impreza. The contact stated that while driving at 65 MPH, the vehicle stalled, and the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with an unknown code for the throttle body. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 162,000.

There is a recall for fuel lines for MY2002-2003 Imprezas and the issue was resolved or a fix was implemented on late MY2004 vehicles. Unfortunately this means early MY2004 vehicles are still impacted by the issue with no recall in place. During cold weather or during cold engine startup fuel lines are prone to leaking onto cylinder head. Raw fuel can be observed dripping, and can be smelled in the engine bay and inside of the vehicle. This poses a fire risk during vehicle operation and the MY2002-2003 recall should be extended to MY2004 vehicles built prior to August 2003.

The contact owns a 2004 Subaru Impreza. The contact received notification of NHTSA Campaign Numbers: 15V323000 (Air Bags) and 11V464000 (Suspension) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The dealer informed the contact that NHTSA Campaign Number: 11V464000 (Suspension) could not be completed due to excessive corrosion. The approximate failure mileage was 191,000. Parts distributions disconnect.

I have already visited my local Subaru dealer to remedy this recall. I have a physical invoice as proof that my vehicle was inspected & already has the correct air bag installed. I have called the recall line (855-371-5406) MANY times & no matter who I speak to the recall does not clear despite me informing them I have already completed the repair. All representatives say the same thing claiming they will "take care of it or speak to a manager" & telling me to wait so it clears on its own over time. It has now been almost 2 years since my visit & I am still receiving an excessive amount of notices. The vehicle works as it should 100% with no issues.

Rubber fuel lines under the intake manifold leak fuel when the temperature falls below 40 degrees F. The smell permeates the cabin and fuel can be seen wetting nearby surfaces under the intake. An inspection can be performed. This represents a fire safety hazard that could occur while the vehicle is in motion, jeopardizing all surrounding traffic. The problem is widely noted on Subaru internet forums, but only a recall for 2002-2003 models has been reported. My car is a very early 2004, so it shares traits of the 2003 engines. There are no warning lamps or notifications, only the smell of raw gas when the car starts and is in motion in winter temperatures. This has happened repeatedly since the issue first occurred, so I avoid driving this vehicle if at all possible.

The passenger side lower control arm failed due to corrosion. There was a previous recall to address this issue with an anti corrosion coating, but it did not prevent the control arm from corroding and failing. I had this addressed at the dealer, and they mentioned the issue was addressed. Recall NHTSA Campaign Number: 11V464000

THERE IS A STRONG FUEL/GASOLINE SMELL COMING THRU THE AIR VENTS FROM THE ENGINE WHEN THE TEMPERATURE GOES UNDER 30-25 DEGREES FARENHEIT. I'VE CHECKED UNDER THE HOOD AND THERE IS TWO FUEL HOSES THAT START LEAKING WHEN IT GETS COLD OUTSIDE. THIS HAS BEEN HAPPENING EVERY WINTER SINCE I GOT MY CAR BACK IN 2016. I HAD THE CLAMPS ON THE HOSES RETIGHTENED BY A SUBARU DEALERSHIP BUT THAT DIDN'T SOLVE THE PROBLEM. I'M WRITING THIS COMPLAINT BECAUSE THERE IS AN OPEN RECALL FOR THIS ISSUE ON THE 2002 AND 2003 WRX, BUT NOT ON THE LATER MODELS. THERE'S MANY PEOPLE ON THE INTERNET WITH THE SAME ISSUE AND IT SEEMS TO BE HAPPENING TO OTHER YEARS OF WRX AND EVEN OTHER MODELS OF SUBARU. IT'S REALLY STRESSFUL AND ANNOYING HAVING THE STRONG SMELL OF FUEL COMING IN TO YOUR CAR. ALSO IT'S A FIRE HAZARD HAVING GASOLINE POOLING UP ON THE ENGINE BLOCK. THIS ISSUE HAS BEEN KNOWN TO SUBARU OF AMERICA BUT THEY ONLY TOOK CARE OF THE 2002 AND 2003 WRX MODELS. I'M HOPING THIS CAN SOMEHOW HELP OTHER SUBARU OWNERS GET THIS PROBLEM FIXED AS IT CAN BE SOMETHING THAT COULD END UP GETTING WORST.

SIMILAR TO RECALL CAMPAIGN #WQK-47 THE HARD BRAKE LINE NEAR MY GAS TANK HAS CORRODED AND LEAKED ALL OF MY BRAKE FLUID. HAD I BEEN ON THE HIGHWAY THIS COULD HAVE BEEN CATASTROPHIC. THE VEHICLE WAS IN MOTION, I NOTICED THE BRAKE PEDAL WAS TRAVELING FARTHER THAN NORMAL. WHEN I GOT HOME, THERE WAS ALMOST NO BRAKING ABILITY LEFT IN THE CAR, PEDAL WENT TO THE FLOOR. CHECKED MASTER CYLINDER, IT WAS EMPTY, ADDED FLUID, PRESSED ON BRAKES, COULD HEAR THE FLUID LEAKING OUT. CHECKED AROUND CAR TO FIND FLUID. THIS IS A COMMON PROBLEM ON SUBARU'S AND THERE IS A RECALL FOR NEWER WRX'S FOR THE SAME ISSUE.