ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS

Dec 22, 2004 — Recall Campaign #04V609000

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

The recall was influenced by the manufacturer with about 3,538 units affected.

See recall notice

NHTSA Safety Recall Notice

04V609000

Manufacturer:	Winnebago Industries, Inc.
Recall date:	December 22, 2004
NHTSA Campaign #:	04V609000
Units affected:	3,538

Description:: ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.
Consequeces:: WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective action:: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.
Notes:: WINNEBAGO RECALL NO. 93. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

Affects the following:

2005 ITASCA SUNCRUISER Complaints
WHILE DRIVING MY ITASCA SUNCRUISER MOTORHOME TO COBB & SON RV REPAIR I NOTICED I WAS UNABLE TO MAINTAIN NORMAL SPEED. ARRIVED AT COBB AND EXPLAINED TO RITCHIE COBB THE PROBLEM I WAS HAVING. RITCHIE HAD A TECH MEASURE THE HEAT AT THE BRAKES AND THEY WERE AT 900 DEGREES. INFORMED RECALL FROM WORKHORSE REGARDING A BRAKE ISSUE AND THAT THE VEHICLE WOULD HAVE TO BE DRIVEN TO AN AUTHORIZED WORKHORSE DEALER FOR REPAIR (100 MILES AWAY). RITCHIE EXPLAINED THIS COULD NOT BE DONE AS THE VEHICLE WAS UNSAFE TO DRIVE AND THERE WOULD BE SERIOUS RISK OF INJURY AND EVEN FURTHER DAMAGE AS THE PADS WERE WORN AND CRYSTALLIZED, CALIPERS BAD, AND THE BRAKE FAILURE HAVE CREATED SERIOUS GROOVES IN THE ROTORS. ADDITIONALLY THE BRAKES HAD ALREADY GONE INTO LOCKING UP MODE. RITCHIE SAID THE REMEDY WAS REPLACEMENT OF ALL THIS PARTS ON ALL 4 BRAKES BECAUSE OF DAMAGE CAUSED BY THE RECALL ISSUE. ASTOUNDED THAT WORKHORSE SAID I WOULD HAVE TO DRIVE THE VEHICLE TO THEIR DEALER FACILITY(100 MILES AWAY), I PERSONALLY CALLED WORKHORSE. I GOT THE SAME ANSWER FROM CUSTOMER SERVICE, THEN THE HEAD OF CUSTOMER SERVICE, THEN THIRDLY FROM CARL DAHL THEIR REGIONAL MANAGER. I REFUSED TO RISK DRIVING THE VEHICLE AND HAD TO HAVE IT TOWED AT MY EXPENSE AS WORKHORSE REFUSED TO DO SO. MY NEXT SURPRISE WAS THAT WORKHORSE WOULD NOT REPLACE ROTORS, PAD, ETC., EVEN THOUGH THEIR RECALL ISSUE CAUSED ALL THE DAMAGE. A POLICY TO TELL SOMEONE TO DRIVE AN UNSAFE VEHICLE AND THEN THEY WOULD TOW IT WHEN I BREAK DOWN ON THE SIDE OF THE ROAD IS INSANE AND IRRESPONSIBLE. FURTHER THEY ARE IGNORING THEIR RESPONSIBILITY TO REPAIR ALL THE DAMAGE THAT WAS CAUSED BY THEIR RECALL. I HAVE NOW HAD TO PAY OVER $1,100 TO RESTORE MY BRAKES, PAY FOR TOWING, AND DRIVE 200 MILES TO PICK UP MY MOTORHOME. I NEED YOUR ASSISTANCE TO PERSUADE WORKHORSE TO DO THE ETHICAL AND HONORABLE THING AND REIMBURSE ALL THE MONEY I HAVE SPENT. *JS;
2005 ITASCA SUNOVA Complaints
2005 WINNEBAGO ITASCO SUNOVA HAS PROBLEMS WITH THE CHASSIS, IT IS UNSAFE TO DRIVE PAST 55M PH RV IS REACTIVE TO SLIGHT WIND GUST FROM SMALL TO LARGE VEHICLES. *TS THE CONSUMER HAD OTHER PROBLEMS WITH THE RV SUCH AS AN INOPERATIVE STOVE TOP O RING, SLIDE OUT FASCIA RIGHT SIDE, DRIVER SIDE AND PASSENGER FENDER BLEW OUT, THE WATER HEATER FAILED, DRIVER SIDE MIRROR HAD BLOWN OFF WHILE DRIVING, A SLIDE OUT LEAK, A TOILET SPRAY LEAK, BATHROOM CAULK CRACKING/SEPARATING, SHOWER CAULK/ SEPARATION, THE KITCHEN WAS DELAMINATING AND THE WALL PAPER WAS BUBBLING;
2005 ITASCA SUNRISE Complaints
THE BRAKE ROTORS ON MY MOTOR HOME HAD TO BE REPLACED DUE TO HEAT FRACTURES IN EVERY ROTOR. IT IS A WORKHORSE CHASSIS MODEL W20. IT HAD 38,400 MILES ON IT AND THERE IS MORE THAN 50% OF THE PAD LINING THICKNESS LEFT. THE PADS WERE REPLACED AT THAT TIME ON THE ADVICE OF THE REPAIR CENTER. I HAVE THE ROTORS AND THE PADS. THE CONDITION WAS FOUND DURING A PERIODIC BRAKE INSPECTION THAT I HAD THE SERVICE CENTER PERFORM. I HAD NO PERFORMANCE ISSUES AT THE TIME. *TR;
2005 WINNEBAGO ADVENTURER Complaints
CONCERNING RECALL 51101-C. THE DEALERS ARE TELLING ME THE ONLY THING COVERED UNDER THIS RECALL IS THE CALIPERS, EVEN THOUGH BECAUSE OF THE CALIPERS, THE ROTORS ARE ALSO DAMAGED. AND THE ABS SENSOR IS MELTED. JUST WONDERING WHAT YOUR INTERPRETATION OF THIS RECALL IS. THANKS FOR YOUR TIME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR;