ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL

Sep 07, 2005 — Recall Campaign #05V388000

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

The recall was influenced by the Office of Defects Investigation with about 4,500,000 units affected.

See recall notice

NHTSA Safety Recall Notice

05V388000

Manufacturer:	Ford Motor Company
Recall date:	September 07, 2005
NHTSA Campaign #:	05V388000
Units affected:	4,500,000

Description:: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequeces:: A FIRE AT THE SWITCH COULD OCCUR.
Corrective action:: BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Notes:: FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

1996 FORD BRONCO Complaints
TRANSMISSION JUMPS OUT OF OVERDRIVE, AFTERWARDS HARD SHIFTS IN ALL GEARS AFTER HIGH RPMS. THE FIX IS TO STOP, CUT THE ENGINE OFF AND THE TRANSMISSION RESETS FOR LACK ON A BETTER TERM. WHEN THE BRONCO IS IN OD AND IS JUST CRUSING, NOT IN A PULL, IS WHEN THE OD JUMPS OUT. LIKE ANY OTHER THING IT DOES NOT HAPPEN ALL THE TIME.;
1999 FORD F-250 Complaints
i was involved in a collision on US30 3 miles west of Rainer Oregon. where I struck another Ford truck while cruising at 55 mph. The vehicle I struck pulled in front of me, my vehicle was severely damaged in the front end and the steering wheel and lower dash panel injured me.,;
2002 FORD EXPEDITION Complaints
Cruise control deactivation switch. I was getting in my truck on my way to work in the early morning. as I walked by the hood I could smell what seemed like burning wire, so I opened the hood & right as I got it all the way up flames started shooting up. I put the fire out and had to wait to call my mechanic he came and told me it was definitely the deactivation switch that had caught fire.;
2002 FORD F-150 Complaints
I had the recall number 05s28 repaired at high desert ford on July sixth as a part of a California safety inspection to register my vehicle. Per ford they are done however they refuse to update the system which holds my vehicle unable to be registered even after the services were rendered and complete. Multiple attempts to trendy have failed any results thus ford is holding my vehicle hostage from legal use in the state;
2002 LINCOLN BLACKWOOD Complaints
TL* THE CONTACT OWNS A 2002 LINCOLN BLACKWOOD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, THE PASSENGER'S SIDE FRONT WHEEL AND BRAKE LINE DETACHED FROM THE VEHICLE WITHOUT WARNING. THE CONTACT STATED HE SHIFTED TO A LOWER GEAR TO STOP THE VEHICLE ON THE SIDE OF THE ROADWAY. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. THE VIN WAS NOT AVAILABLE.;