2002 FORD F-150 Complaints

I had the recall number 05s28 repaired at high desert ford on July sixth as a part of a California safety inspection to register my vehicle. Per ford they are done however they refuse to update the system which holds my vehicle unable to be registered even after the services were rendered and complete. Multiple attempts to trendy have failed any results thus ford is holding my vehicle hostage from legal use in the state

Cruise control kicked on and won't go off. Gas fumes come from the AC unit. When driving the truck started speeding up. Now the truck is parked.

Front seatbelts on 2002 Ford F-150 become unlatched unexpectedly while driving. This has been noticed over the last two or three years occasionally, but has been getting worse. Seat belt has become unlatched about 5-6 times during a 600 mile road trip. Seat belt was confirmed by two passengers that it was indeed latched correctly and nothing pushing the release button. Seatbelt was confirmed to be latched by firmly tugging on seat belt to witness that it was latched. Both passengers confirmed that the seatbelt become unlatched randomly while driving. Passenger and driver safety is at risk. If driver seatbelt comes unlatched while driving or during accident, the driver could loose control of truck and put other drivers at risk. The unlatching does not show any warning signs as to when it will become unlatched. Seatbelt just becomes unlatched and starts to recoil without warning. Ford service just says that the truck is out of warranty and that they dont cover seat belt replacements as there is no open recalls for such. Seatbelt is still currently installed on vehicle but can be available for inspection on vehicle or removed for inspection.

DRIVING DOWN [XXX] THE STRAPS ON MY GAS TANK BROKE BECAUSE THEY RUSTED THRU CAUSING GAS TANK TO DROP AND SPILL FUEL ALL OVER [XXX] IN IOWA CAUSING SO MUCH FUEL SPILLED OUT THEY HAD TO CLOSE ONE LANE OF TRAFFIC....THE FIRE DEPT CHIEF OF WHITING, IOWA, STEVEN SNYDER, Can verify what happened....THERE IS A POLICE REPORT BUT I DIDN'T HAVE IT FILING OUT THIS REPORT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2002 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle made a loud sound. No warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed and determined that cylinder #3 spark plug had blown out, but no repair was recommended at the time. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 108,000.

The contact owns a 2002 Ford F-150. The contact stated while at a tire shop to have the tires rotated, the mechanic was unable to remove the tires due to the lug nuts being swollen. The manufacturer was made aware of the failure and suggested to the contact to call the NHTSA Hotline to report the failure. The approximate failure mileage was 100,000.

The contact owns a 2002 Ford F-150. The contact stated that the rear driver's side and rear passenger's side doors failed to open from inside or outside the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact stated that the vehicle was previously serviced due to the failure. The failure mileage was 70,000.

The contact owns a 2002 Ford F-150. The contact stated that she observed smoke emanating from under the vehicle near the engine compartment. The contact stated that she opened the hood and flames erupted from the engine compartment near the battery. The contact threw dirt on the engine to extinguish the fire. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 200,000.

The contact owns a 2002 Ford F-150. The contact stated that while driving approximately 45 MPH and attempting to pass a slower vehicle, the vehicle experienced unintended acceleration. The contact stated that while depressing the accelerator pedal, the pedal suddenly extended to the floorboard causing the vehicle to immediately accelerate faster than intended. During the failure the speed increased to over 75 MPH before the contact shifted the transmission into neutral and the vehicle decelerated. The contact stated that the vehicle had experienced the failure on two other occasions and the cruise control feature was never activated during the failure. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 94,000.

The contact owned a 2002 Ford F-150. The contact stated that while his wife was driving at 50 MPH, she crashed into a tree. The air bags failed to deploy upon impact. The contact's wife was taken to the hospital where she was treated for a concussion, multiple hematomas to her right thigh, right abdomen, and head; as well as three fractures on her vertebrae. A police report was filed. The vehicle was towed from the scene to an independent tow yard where it remained in their possession. The dealer nor the manufacturer had been notified of the failure. The contact was informed by his insurance that the vehicle was a total loss. The failure mileage was approximately 280,000.