CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION

Oct 05, 2005 — Recall Campaign #05V455000

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.

The recall was influenced by the manufacturer with about 123,592 units affected.

See recall notice

NHTSA Safety Recall Notice

05V455000

Manufacturer:	Isuzu Motors Limited
Recall date:	October 05, 2005
NHTSA Campaign #:	05V455000
Units affected:	123,592

Description:: CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequeces:: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective action:: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:: GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2006 BUICK RAINIER Complaints
The contact owns a 2006 Buick Rainer. The contact stated that while driving at various speeds, the steering wheel jerked independently without warning, causing the contact to lose control of the vehicle. In addition, the contact stated that there was an abnormal grinding sound coming from the brake pedal while depressing the brake pedal. The contact had taken the vehicle to two independent mechanics, where the wheel bearings and ball joints were replaced; however, the failure persisted. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was unknown.;
2006 CADILLAC ESCALADE ESV Complaints
THE BRAKE LINES WERE CORRODED AND LEAKING IN AT LEAST TWO LOCATIONS. THE DEALER MASSEY CADILLAC OF SOUTH ORLANDO HAD TO REPLACE FROM THE REAR AXLE TO THE MASTER CYLINDER. THIS HAPPENED WHILE WE WERE DRIVING ON INTERNATIONAL DRIVE ON OUR WAY HOME TO MC.;
2006 CHEVROLET CORVETTE Complaints
The contact owns a 2006 Chevrolet Corvette. The contact became aware that the VIN was included in NHTSA Campaign Number: 09V491000 (Structure). The vehicle was taken to the local dealer, where the contact was informed that the recall part was no longer available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the part had been discontinued. The contact was advised to purchase the part from a junkyard or to order an entire roof from the dealer at his expense. The contact had not experienced a failure.;
2006 CHEVROLET EXPRESS Complaints
I was driving approximately 70 mph on the highway when I came up behind a vehicle whose three brake lights were completely inoperative. The vehicle suddenly stopped, but there was no brake light illumination to warn following traffic. The only reason I realized the vehicle was stopping was because I was traveling on a slope and could see the vehicles ahead of it also slowing down. If the roadway had been level, I likely would not have known the vehicle was braking and could have rear-ended it at highway speed. This created a serious safety hazard and put me and other drivers at significant risk of a high-speed collision.;
2006 CHEVROLET SILVERADO 1500 Complaints
Purchased these aftermarket nylon rear axle lift blocks (level kit) online . They failed while the vehicle was in motion in the live lane on the highway. I was barely able to pull off the road . These blocks are not safe for regular road or highway use. They failed under normal driving on a otherwise stock 1/2 ton 1500 truck . I could have been on a freeway and or other highway with more traffic and this part could have caused a accident as both of these plastic nylon rear axle blocks collapsed under the weight of the truck.;