ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES

Aug 01, 2006 — Recall Campaign #06V286000

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

The recall was influenced by the Office of Defects Investigation with about 1,200,000 units affected.

See recall notice

NHTSA Safety Recall Notice

06V286000

Manufacturer:	Ford Motor Company
Recall date:	August 01, 2006
NHTSA Campaign #:	06V286000
Units affected:	1,200,000

Description:: ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequeces:: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Corrective action:: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
Notes:: FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

1996 FORD CLUB WAGON Complaints
FUEL FILLER PIPE ON THIS VEHICLE HAS FAILED THREE TIMES (FIRST FAILURE MILEAGE IS LISTED BELOW). EACH TIME THE FIRST SYMPTOM IS THE SMELL OF FUEL OUTSIDE THE VEHICLE AFTER DRIVING, WHEN THE PROBLEM WORSENS, AT TIME OF FILL-UP GAS SPILLS ON THE GROUND. *TR;
1996 FORD E-150 Complaints
MY VEHICLE ACCORDING THE NHTSA HAS RECALL #09V399000 FOR THE BRAKE SYSTEM SPEED CONTROL WHICH CAN CATCH ON FIRE EVEN IN THE GARAGE WITH THE VEHICLE OFF. I ASKED FORD TO REPAIR THIS BECAUSE I JUST BOUGHT THIS VEHICLE AND THEY CLAIM THERE ARE NO RECALLS ON THIS VEHICLE, AND I KNOW THERE IS AND I KNOW THE RECALL HASN'T BEEN INSTALLED ON MY VEHICLE. ARE THEY SAYING THIS BECAUSE TIME RAN OUT TO HAVE THIS DONE BECAUSE I JUST BOUGHT THIS VEHICLE OR DO THEY JUST NOT WANT TO? THANKS FOR YOUR HELP. *JS;
1996 FORD E-250 Complaints
I WAS STOPPED AT AN INTERSECTION WITH TRUCK IN GEAR AND CLUTCH PEDAL DOWN, ALL OF A SUDDEN THE CLUTCH RELEASED WITH THE PEDAL STILL DOWN CAUSING THE TRUCK TO LURCH INTO THE STREET ABOUT 15 FT BEFORE I COULD STOP WITH THE BRAKES. THE CARS IN THE STREET WERE ABLE TO AVOID ME BUT I WAS VERY SHAKEN. I FOUND THE PROBLEM WAS THE "CLUTCH ROD END PLASTIC BUSHING AND RETAINER" HAD FAILED ALLOWING THE CLUTCH TO RELEASE WITHOUT THE PEDAL. THIS WAS REPLACED BUT FAILED AGAIN 6 MONTHS LATER. FORTUNATELY I ALWAYS KEEP THE TRUCK IN NEUTRAL WHEN STOPPED NOW SO IT WAS ONLY AN INCONVENIENCE. CHECKING THE INTERNET FOR A FIX I FOUND SEVERAL COMPANIES THAT MAKE A REPLACEMENT ASSEMBLY FOR THIS BECAUSE OF ALL THE FAILURES. I HAVE BEEN KEEPING THE "ROD END" IN PLACE WITH WIRE AND ALWAYS KEEP IN NEUTRAL TO PREVENT ANOTHER FAILURE BUT HAVE ORDERED A REPLACEMENT ASSEMBLY AN EBAY COMPANY TO PREVENT THIS VERY DANGEROUS FAILURE FROM HAPPENING AGAIN. WHY HASN'T FORD NOTIFIED ANYONE ABOUT THIS POSSIBLE CATASTROPHIC AND LIFE THREATENING FAILURE AND AT LEAST SUPPLIED PARTS TO FIX THIS CORRECTLY. *TR;
1996 FORD E-350 Complaints
APPROXIMATELY 6 TIMES ON A 800 MILE ROAD TRIP WHEN IT WAS 90 DEGREES OR HOTTER IN THE AFTERNOON MY 1996 E350 MOTORHOME WOULD STOP RUNNING AT HIGHWAY SPEED STRANDING US IN A DANGEROUS SITUATION ON I40. AFTER SITTING IDLE FOR 30-60 MINUTES IT WOULD START AND RUN MAYBE 30 MILES AND STOP. IN THE COOL OF THE EVENING OR MORNING IT WOULD RUN AS LONG AS NEEDED. THE PROBLEM IS AN INADEQUATE FUEL PUMP WHICH IS WELL DOCUMENTED ON MANY INTERNET BLOGS. IN MID YEAR 1996 FORD UPGRADED TO A TURBINE FUEL PUMP WHICH I HAVE NOW PAID $450 TO INSTALL. THIS UPGRADE SOLVES THE PROBLEM. I WAS ALSO STRANDED AT MAJOR INTERSECTIONS ALSO. I READ THERE MIGHT HAVE BEEN A RECALL FOR THIS PROBLEM WHICH I CANNOT FIND. MY UNDERSTANDING OF THE PROBLEM IS THAT THE ORIGINAL FUEL PUMP WAS A GEROTOR WHICH CAUSED CAVITATION OF FUEL WHICH CAUSED AIR TO REACH THE FUEL RAIL CAUSING THE VAPOR LOCK LIKE PROBLEM.;
1996 FORD ECONOLINE Complaints
TL* THE CONTACT OWNS A 1996 FORD ECONOLINE. THE CONTACT STATED THE DOOR LATCH WOULD NOT RELEASE OPEN IN ORDER TO GAIN ACCESS OR EXIT THE VEHICLE DUE TO THE FAULTY DOOR CABLE. THE FAILURE INVOLVED BOTH SIDE DOORS AND REAR DOOR. THE CONTACT PURCHASED THE DOOR CABLE KIT AND PERFORMED THE REPAIR HIMSELF. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 01/20/12*LJ THE CONSUMER STATED THERE WAS A FLAW IN THE MECHANICS THAT OPERATES THE DOORS THAT CAN BECOME INOPERABLE WITHOUT WARNING. THE CABLES OPERATING THE LATCHES CAN AND DO FAIL BECAUSE THEY ARE MADE OF VINYL AND IN TIME FAIL. UPDATED 01/20/12;