1996 FORD E-150 Complaints

MY VEHICLE ACCORDING THE NHTSA HAS RECALL #09V399000 FOR THE BRAKE SYSTEM SPEED CONTROL WHICH CAN CATCH ON FIRE EVEN IN THE GARAGE WITH THE VEHICLE OFF. I ASKED FORD TO REPAIR THIS BECAUSE I JUST BOUGHT THIS VEHICLE AND THEY CLAIM THERE ARE NO RECALLS ON THIS VEHICLE, AND I KNOW THERE IS AND I KNOW THE RECALL HASN'T BEEN INSTALLED ON MY VEHICLE. ARE THEY SAYING THIS BECAUSE TIME RAN OUT TO HAVE THIS DONE BECAUSE I JUST BOUGHT THIS VEHICLE OR DO THEY JUST NOT WANT TO? THANKS FOR YOUR HELP. *JS

VEHICLE WAS PARKED, AND UPON ENTERING NOTICED THE SMELL OF AN ELECTRICAL FIRE. STARTED THE VEHICLE, ODOMETER WAS INOPERABLE AND VEHICLE WOULD NOT SHIFT OUT OF PARK. UPON FURTHER INSPECTION, FOUND A BLOWN 15 AMP FUSE IN THE FUSE PANEL. REPLACED FUSE, ODOMETER CAME BACK ON AND VEHICLE SHIFTED OUT OF PARK. APPROXIMATELY 10 SECONDS LATER, THE SMELL OF BURNING WIRING WAS EVIDENT, AS WAS SMOKE FROM UNDER THE HOOD. PULLED THE FUSE BACK OUT, OPENED THE HOOD TO FIND THE BRAKE PRESSURE SWITCH ON FIRE, WHICH MELTED THE BRAKE FLUID RESERVOIR AS WELL AS THE BATTERY CASING ALSO. *TR

A CHROME COLOR GRILLE ABOUT 2.5 FEET WIDE AND 6" TALL FLEW OFF THE FRONT OF OUR 1996 F150 FORD VAN WHILE WE WERE DRIVING AT HIGHWAY SPEED. I NOTICED OTHER SIMILAR FORD VANS THAT HAVE ALSO LOST THE SAME FRONT GRILL PART. WE WERE GOING 55 MPH DOWN A 2 LANE HIGHWAY AND A LARGE TRUCK WAS GOING THE OTHER WAY. THE GUST OF AIR FROM THE PASSING TRUCK WAS SUFFICIENT TO TEAR OFF THE GRILL PART AND CAUSE IT TO FLY OVER THE TOP OF OUR VAN. *TR

TL*THE CONTACT OWNS A 1996 FORD E-150. WHENEVER THE CONTACT STARTS THE ENGINE AND DEPRESSES THE ACCELERATOR PEDAL, THE ENGINE BECOMES STUCK AT A HIGH RPM AND WILL NOT RETURN TO THE IDLE POSITION. THE FAILURE CAUSES THE VEHICLE TO EITHER SURGE FORWARD OR BACKWARDS DEPENDING ON WHAT GEAR IT IS IN AT THE TIME. THE ENGINE HAS TO BE TURNED OFF IN ORDER TO RESTORE THE VEHICLE TO A PROPER SPEED. IN ADDITION, THE BRAKES DO NOT HOLD OR STOP THE VEHICLE WHEN THEY ARE ENGAGED. THE FIRST TIME THIS FAILURE OCCURRED, THE VEHICLE CRASHED INTO A TREE AT 10 MPH. THERE WERE NO INJURIES; HOWEVER, THE REAR WINDOW WAS DAMAGED. THROUGH RESEARCH, THE CONTACT FOUND NUMEROUS ISSUES WITH THIS DEFECT ON THE SAME MAKE AND MODEL VEHICLES. THE VEHICLE WAS TAKEN TO A REPAIR SHOP TWICE. DURING THE FIRST VISIT, THE MECHANIC CLEANED OUT THE ENGINE, ENGINE THROTTLE, AND CABLES. THE FAILURE WAS CORRECTED FOR TWO MONTHS BEFORE IT RECURRED AGAIN. DURING THE SECOND VISIT, THE VEHICLE WAS TOWED TO THE SHOP AND THE MECHANIC CHECKED TO MAKE SURE THAT EVERYTHING WAS LUBRICATED PROPERLY. THE SHOP DID NOT GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE CONTACT BELIEVES THAT A RECALL SHOULD BE ISSUED. THE FAILURE MILEAGE WAS 150,000 AND CURRENT MILEAGE WAS 152,000.

1996 FORD E-150 SERPENTINE BELT, AIR CONDITIONING COMPRESSOR. ELECTRICAL SYSTEM, IGNITION MODULE REPLACED, ABS LIGHT ILLUMINATED WHEN BRAKES WERE APPLIED, TIE RODS REPLACED, FUEL PUMP REPLACED. *KB

BROKEN FRONT SPRING ON 1996 ECONOLINE VAN APPARENTLY DUE TO CORROSION ISSUE. DEALER DIAGNOSED PROBLEM AND STATES THAT BROKEN SPRING MAY OR MAY NOT COME LOSE AND RESULT IN A SAFETY HAZARD. *NM

DT*: THE CONTACT STATED THE VEHICLE CAUGHT FIRE WHILE PARKED. THE FIRE WAS LOCALIZED UNDER THE HOOD. THE VEHICLE WAS NOT TAKEN IN FOR SERVICE. A POLICE REPORT WAS TAKEN. THERE WAS A NHTSA RECALL # 06V286000 WHICH PERTAINED TO THE VEHICLE SPEED CONTROL. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. *AK

DT: THE CALLER SAID THAT WHILE AT WORK HIS VEHICLE CAUGHT ON FIRE. IT WAS SITTING FOR 2 HOURS AND 15 MINUTES. VEHICLE WAS SITTING ACROSS THE STREET FROM WHERE THE CALLER WORKED, AND THE NEIGHBORS SAW THE FIRE AND HELPED PUT IT OUT ALONG WITH A PASSING POLICE OFFICER. FIRE WAS CAUGHT IN TIME, AND NO OTHER DAMAGE WAS CAUSED. DEALER /MANUFACTURER HAD NOT BEEN CONTACTED. *AK

1996 FORD E150 EXPERIENCED BRAKE FAILURE DUE TO CORRODED BRAKE LINES.*MR THE FAILED PART WERE AT THE ABS CONTROL VALVE AND EXTENDED TO THE FRONT BRAKES. FOUR MONTHS PRIOR TO THE FAILURE THE ABS LIGHT ILLUMINATED ON THE DASH. *NM

1. I WAS TRAVELING A 35 MPH ON A STRAIGHT ROAD DURING THE DAYLIGHT HOURS. THE ROAD WAS DRY. THE WEATHER WAS SUNNY, AND THERE WAS VERY LITTLE TRAFFIC IN A TWO LANE ROAD. AS I APPROACHED STANDING TRAFFIC AT A TRAFFIC LIGHT I BEGAN TO SLOW GRADUALLY WITH ENGINE BRAKING. AS I APPOACHED THE STOPPED CAR I BEGAN TO TOUCH THE BRAKE PEDAL, AND IMMEDIATELY NOTICED NO BRAKING EFFECT. I THAN PRESSED THE PEDAL A COUPLE MORE INCHES, AND STILL THERE WAS LITTLE BRAKING EFFECT. I THEN PRESSED AS HARD AS I COULD, AND THE VEHICLE BEGAN TO SLOW GRADUALLY, BUT NOT IN TIME TO AVOID HITTING THE CAR STOPPED AT THE TRAFFIC LIGHT. THERE WAS MINOR DAMAGE DONE TO THE STANDING VEHICLE, BUT ONLY BECAUSE I WAS TRAVELING SO SLOWLY AND HAD BEGUN TO ANTICIPATE THE STOP IN PLENTY OF TIME. HAVING BEEN AN AUTOMOBILE MECHANIC IN YEARS PAST, I DETERMINED THAT THE FAULT WAS IN THE VACUUM BOOSTER OF THE BRAKE SYSTEM. I TOOK THE VEHICLE TO AN AUTHORIZED REPAIR SHOP AND HAD THE BRAKE SYSTEM EVALUATED. THEY EXAMINED THE ENTIRE BRAKE SYSTEM AND COULD FIND NO REASON FOR THE FAILURE. THEY SAID THAT IT COULD HAVE BEEN A MOMENTARY FAILURE OF THE ABS OR VACUUM BOOSTER SYSTEMS, BUT THEY COULD NOT DETERMINE THE FAULT UNLESS IT HAPPENED AGAIN WHILE THEY WERE TESTING THE VEHICLE. I WOULD LIKE TO KNOW IF THIS SAME PROBLEM HAS HAPPENED TO OTHERS.*AK