ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES

Aug 03, 2007 — Recall Campaign #07V336000

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

The recall was influenced by the Office of Defects Investigation with about 3,600,000 units affected.

See recall notice

NHTSA Safety Recall Notice

07V336000

Manufacturer:	Ford Motor Company
Recall date:	August 03, 2007
NHTSA Campaign #:	07V336000
Units affected:	3,600,000

Description:: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequeces:: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Corrective action:: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Notes:: FORD RECALL NO. 05S28.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

1993 FORD BRONCO Complaints
MY 1993 FORD BRONCO HAS AN ESOF (ELECTRONIC SHIFT ON THE FLY) TRANSFER CASE. WITH FOUR WHEEL DRIVE ENGAGED, ON ROAD AND OFF, WHENEVER THE VEHICLE IS COASTING THE TRUCK WILL SUDDENLY ACT LIKE IT IS NO LONGER IN GEAR. SHIFTING INTO PARK AND AND BACK WILL NOT CHANGE ANYTHING. THE TRUCK MUST BE TAKEN OUT OF FOUR WHEEL DRIVE IN ORDER TO START DRIVING AGAIN. I BELIEVE THIS TO BE DANGEROUS AS IT COULD ALLOW ME TO NOT REACT IN THE CASE OF AN EMERGENCY. IT THINK THAT IT IS A SIMILAR PROBLEM TO THE RECALL 93V089000.;
1993 FORD F-250 Complaints
TL* THE CONTACT OWNS A 1993 FORD F-250. WHILE THE CONTACT WAS FUELING THE VEHICLE, THE FUEL CAP SHRANK AND FUEL SPEWED FROM THE FUEL TANK. THE FAILURE OCCURRED WHENEVER HE ATTEMPTED TO FUEL THE FRONT TANK FIRST. AS THE FUEL TRAVELED TO THE REAR TANK, IT SPEWED OUT. THE CONTACT STATED THAT THE FAILURE WAS A FIRE HAZARD. THE CONTACT DROVE THE VEHICLE TO FUTURE FORD OF ROSEVILLE (650 AUTOMALL DR, ROSEVILLE, CA 95661, (888) 656-7577), BUT THE MECHANICS REFUSED TO SERVICE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000.;
1993 FORD F-350 Complaints
TL* THE CONTACT OWNS A 1993 FORD F-350 EQUIPPED WITH BCT HI-RUN TIRES, SIZE L235/85R16 (NA). WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE TREADS WERE SEPARATING FROM THE TIRES AND THE TIRES NEEDED TO BE REPLACED. WHILE AT THE INDEPENDENT MECHANIC, THE OTHER THREE TIRES BLEW OUT. THE TIRES WERE NOT REPAIRED. THE TIRES WERE NOT ORIGINAL EQUIPMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 190,000 AND THE TIRE FAILURE MILEAGE WAS 4,000. THE VIN AND DOT NUMBER WERE NOT PROVIDED.;
1993 FORD F-450 SD Complaints
DUEL TANKS IN VEHICLE AND ONE TANK EMPTIES INTO OTHER, CAUSING ONE TO OVERFLOW. IT'S CAUSED BYA CROSS VALVE NOT FUNCTIONING, SHUTING OFF FROM NON OPERATING TANK. REPAIR COST IS $800. DEALER IS NOT AUTHORIZING REPAIRS.*AK;
1994 MERCURY CAPRI Complaints
FRED MARTIN FORD 4701 MAHONING AVE YOUNGSTOWN, OHIO (330) 793-2444 REFUSED TO COMPLETE SAFETY RECALL FOR THE SPEED CONTROL ON MY 1994 MERCURY CAPRI. THEY SAY THEY ARE NOT QUALIFIED TO DO THE RECALL BUT DID WORK ON THE FIRST PART OF THE RECALL (DISCONNECTING THE SWITCH) BUT REFUSE TO REPLACE THE PART SPECIFIED IN THE RECALL. I CALLED TODAY (JULY23RD) AND WAS TOLD WE DON'T WORK ON MERCURY VEHICLES AFTER THEY HAD ALREADY WORKED ON IT. *TR;