ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES

Nov 15, 2006 — Recall Campaign #06V441000

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

The recall was influenced by the Office of Defects Investigation with about 170,099 units affected.

See recall notice

NHTSA Safety Recall Notice

06V441000

Manufacturer:	Volvo Car USA, LLC
Recall date:	November 15, 2006
NHTSA Campaign #:	06V441000
Units affected:	170,099

Description:: ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequeces:: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Corrective action:: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Notes:: VOLVO RECALL NO. R155. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2000 VOLVO S70 Complaints
I am filing this complaint because my 2000 Volvo S60 is experiencing a safety failure regarding the Front, driver door latch/lock. The door fails to latch properly. While there is a known safety recall (e.g., recall R89978) for this exact issue on the 2000 Volvo S60, my VIN shows as 'not affected' on the NHTSA lookup tool. My vehicle is exhibiting the exact safety defect that the recall is intended to fix, yet I am not covered. I request that NHTSA investigate why this VIN is excluded despite having the same safety defect, posing a significant risk.;
2000 VOLVO V70XC Complaints
PULLING OUT OF PHYSICAL THERAPY PARKING LOT UNTO SOUTH PARK AVE. IN HAMBURG NY 14075, ENGINE STALLED IN MIDDLE LANE. BARELY MADE IT ACROSSTO CURBSIDE AND STALLED AGAIN, PATROL CAR CAME AND ASSISTED ME WITH HIS FLASHING LIGHTS. VEHICLE STILL NOT IN RUNNING CONDITION. TRIED NEW PARTSWITH OUT SUCCESS.GOING TO MECHANIC. *TR;
2001 VOLVO S80 Complaints
Takata recall. The contact owns a 2001 Volvo S80. The contact received a notification for NHTSA Campaign Number: 21V766000 (Air Bags). The dealer had been notified about the recall; however, the contact was informed that the part was not yet available. The manufacturer was then notified and informed him that they were unaware of when the parts may have become available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnection.;
2001 VOLVO XC70 Complaints
TL* THE CONTACT OWNS A 2001 VOLVO XC70. WHILE DRIVING 35 MPH, THE VEHICLE INDEPENDENTLY STOPPED. THE VEHICLE WAS ABLE TO RESTART; HOWEVER, IT SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (MITCHELL VOLVO CARS OF SIMSBURY 384 HOPMEADOW STREET, SIMSBURY, CT 06070) WHERE IT WAS DIAGNOSED THAT THE THROTTLE MODULE NEEDED AN UPDATE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER SENT AN ELECTRICAL SPECIALIST TO THE LOCAL DEALER TO PROPERLY DIAGNOSE THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.;
2002 VOLVO C70 CONVERTIBLE Complaints
TL* THE CONTACT OWNS A 2002 VOLVO C70 CONVERTIBLE. WHILE DRIVING 25 MPH, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE ELECTRONIC THROTTLE CONTROL LIGHT ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,877.;