CHRYSLER IS RECALLING 1,585 MY 2007-2008 JEEP WRANGLER, RIGHT HAND DRIVE ONLY

May 06, 2008 — Recall Campaign #08V202000

CHRYSLER IS RECALLING 1,585 MY 2007-2008 JEEP WRANGLER, RIGHT HAND DRIVE ONLY, VEHICLES. SOME VEHICLES MAY HAVE INSUFFICIENT CLEARANCE BETWEEN THE STEERING INTERMEDIATE SHAFT AND REAR BRAKE TUBES.

The recall was influenced by the manufacturer with about 1,709 units affected.

See recall notice

NHTSA Safety Recall Notice

08V202000

Manufacturer:	Chrysler (FCA US, LLC)
Recall date:	May 06, 2008
NHTSA Campaign #:	08V202000
Units affected:	1,709

Description:: CHRYSLER IS RECALLING 1,585 MY 2007-2008 JEEP WRANGLER, RIGHT HAND DRIVE ONLY, VEHICLES. SOME VEHICLES MAY HAVE INSUFFICIENT CLEARANCE BETWEEN THE STEERING INTERMEDIATE SHAFT AND REAR BRAKE TUBES.
Consequeces:: PROLONGED BRAKE TUBE CONTACT COULD WEAR A HOLE IN THE TUBE AND CAUSE A PARTIAL BRAKE SYSTEM LOSS. THIS COULD CAUSE A CRASH WITHOUT WARNING.
Corrective action:: DEALERS WILL INSTALL A REVISED BRAKE TUBE CLIP TO RETAIN THE TUBES, INSPECT THE BRAKE TUBES FOR DAMAGE DUE TO POTENTIAL CONTACT WITH THE STEERING INTERMEDIATE SHAFT, AND REPLACE THE BRAKE TUBES IF NECESSARY. THE RECALL BEGAN ON JUNE 30, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Notes:: CHRYSLER RECALL NO. H17.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2007-2008 JEEP WRANGLER

2008 JEEP WRANGLER Complaints
"On March 4, 2022, Customer Satisfaction Notification S33 (Airbag Clockspring Recall Remedy) was performed on my 2008 Jeep Wrangler by an authorized dealer at 123,314 miles. The vehicle now has 137, 347 miles. The replacement clockspring provided as the official safety remedy has completely failed after only roughly 15,000 miles of driving, illuminating the SRS airbag warning light and completely disabling the supplemental restraint system. The manufacturer's mandated remedy has failed to permanently correct the safety defect, creating a recurring hazard." Tom O'Brian dealership and Stellanis have both refused to repair clockspring which is either defective repair item. "Stellantis corporate directed me to speak with you directly regarding a safety component failure. Tom O’Brien Jeep performed the S33 clockspring campaign on my Wrangler at 123,314 miles. The vehicle only has about 138,000 miles on it now. This critical airbag safety component failed after just 15,000 miles of driving. Corporate told me that if you submit a Digital Goodwill Claim through the dealer portal for an internal part failure on a safety campaign, they can review it for approval. Because this disables my entire airbag system after only 15,000 miles, I am asking you to submit that goodwill request so Stellantis can cover the replacement." ," no federal safety regulator or corporate executive expects a vital component of a vehicle's supplemental restraint/airbag system to fail after just 15,000 miles. This extremely low mileage proves one of two things: either the replacement remedy part was defective out of the box, or the "dust shroud" modification required by the S33 campaign was not installed correctly, allowing the new clockspring to fail prematurely.;