VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM

May 21, 2009 — Recall Campaign #09V173000

VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.

The recall was influenced by the manufacturer with about 127,764 units affected.

See recall notice

NHTSA Safety Recall Notice

09V173000

Manufacturer:	Volvo Trucks North America
Recall date:	May 21, 2009
NHTSA Campaign #:	09V173000
Units affected:	127,764

Description:: VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
Consequeces:: IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.
Corrective action:: VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Notes:: VOLVO TRUCKS RECALL NO. RVXX0902.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2008 VOLVO VHD Complaints
REPAIRS ON A CLASS 8 OVER THE ROAD TRACTOR, TWO FUEL PUMP HAS BEING INSTALL WITH NO,RESORT THE THIRD ONE WILL BE INSTALL ON FRIDAY THE 23 OF JANUARY HOPING THAT WILL BE ENOUGH TO DO THE JOB. *TR;
2008 VOLVO VNL Complaints
TL* THE CONTACT OWNS A 2008 VOLVO VNL. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR AN INSPECTION WHERE IT WAS INFORMED THAT THE STEERING COLUMN WAS FRACTURED. THE VEHICLE WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. PRIOR TO THIS PARTICULAR FAILURE, THE VEHICLE HAD THE STEERING COLUMN REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 10V282000 (STEERING) HOWEVER THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 80,605.;
2008 VOLVO VNM Complaints
THE FOLLOWING COMPLAINT IS REGARDING A 2008 VOLVO TRUCK (MODEL VNM 200, 2 AXLE DAYCAB). I WAS DRIVING THIS MODEL OF TRUCK PULLING TWO TRAILERS AT THE TIME OF MY CRASH. THIS VEHICLE SUSTAINED SIGNIFICANT FRONT-END DAMAGE. HOWEVER, THE AIRBAG FAILED TO DEPLOY. THIS ACCIDENT OCCURRED ON INTERSTATE 15 NEAR EXIT 36 IN UTAH. I WAS TRAVELING SOUTHBOUND AT APPROXIMATELY 55 MPH WHEN I COLLIDED WITH A BOULDER. THE IMPACT WITH THE BOULDER WAS NEAR THE FRONT RIGHT CORNER OF THE BUMPER, ALSO STRIKING THE RIGHT STEER TIRE AND HITTING VARIOUS OTHER PARTS OF THE RIG. AFTER COLLIDING WITH THE BOULDER I FOUGHT TO KEEP THE VEHICLE STRAIGHT FOR ABOUT 2 TO 4 SECONDS. AFTER THIS, THE TRACTOR BEGAN TO VEER OFF TO THE RIGHT ON ITS OWN, SUBSEQUENTLY CRASHING INTO A STEEP EMBANKMENT. THIS IMPACT WAS WITH THE LEFT FRONT PART OF THE TRUCK. ULTIMATELY THE TRUCK AND FRONT TRAILER ROLLED ONTO THEIR LEFT SIDES COMING TO REST FACING NORTH. THE IMPACT WITH THE EMBANKMENT WAS SO SEVERE THAT THE ENGINE WAS PUSHED BACK AND EVEN THE INTERIOR CENTER CONSOLE WAS PUSHED BACK AGAINST THE GEARSHIFT. THE LIGHT SWITCH POPPED OUT AS WELL AS VARIOUS OTHER INTERIOR PANELS. THE RIGHT EXTERIOR MIRROR SWUNG ALL THE WAY FORWARD FROM THE IMPACT. THE STEERING WHEEL WAS BENT UPWARDS. MY INJURIES ARE CONSISTENT WITH BEING THROWN FORWARD; BROKEN NECK, BROKEN BACK, BROKEN RIBS, LEFT SHOULDER SPRAIN, AND KNEE CONTUSIONS. I SUFFERED THESE INJURIES EVEN THOUGH I WAS WEARING MY SEAT BELT. I HOPE THAT THIS COMPLAINT WILL BE INVESTIGATED FURTHER. *TR;