NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN

Oct 28, 2010 — Recall Campaign #10V517000

NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.

The recall was influenced by the manufacturer with about 747,480 units affected.

See recall notice

NHTSA Safety Recall Notice

10V517000

Manufacturer:	Nissan North America, Inc.
Recall date:	October 28, 2010
NHTSA Campaign #:	10V517000
Units affected:	747,480

Description:: NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequeces:: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Notes:: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2006 INFINITI QX56 Complaints
Air bag not working, horn not working properly. And other functions. Was told clock spring needs to be replaced.;
2006 NISSAN ARMADA Complaints
Earlier in the year the brake light (some times with slip and ABS) came on the dash and suddenly braking was diminished. There was a horrid grinding sound plus vibration under the pedal. I was on highway 17 (a dangerous mountain freeway in CA) going downhill and it was extremely scary as has a car full of friends kids and hardly any brakes. I braked as much as it would allow, down shifted and pulled to the side (which again if you google that highway people die all the time from idiot drivers/speeders/tight corners). I instinctively turned off the car and got out to check off something had gotten caught in my wheel but nothing. I turned the car on and the problem had gone so drove to the nearest garage but he couldn't find anything wrong. I called Nissan but they said they knew of no problems with breaking systems on the Armada and said to bring it in and pay for an expensive diagnosis. When I got home I googled it and found 100s of similar experiences with all sorts of repairs at Nissan that hadn't worked. Some say brake booster, others sensor, other reset or upgrade hardware. Not one actually fix so far but I did find a couple of lawsuits for the same reason so don't understand how this is not a recall. The second time I was in town so it wasn't too bad but hard to stop at the crossing for a pedestrian and today it went again going back up the mountain but luckily don't need to brake much going in that direction. If it can't be fixed and it involves brakes then surely this is a serious safety violation. I also noticed that others are having a similar problem with newer Armadas with a newly upgraded braking system from Nissan and another lawsuit is on file. How is this being ignored? My car is 20 and I was looking into another Nissan but if they don't stand by and honor their mistakes then I really have no faith in them;
2006 NISSAN FRONTIER Complaints
Whenever I fill ip the tank I get a fuel smell inside the vehicle. I do not overfill the tank and always stop filling when the fuel pump stops the first time. I have not been able to identify a leak and have not seen fuel leaking under the vehicle. The smell is strong for about the first 1/4 tank of use.;
2006 NISSAN PATHFINDER Complaints
I've ran out of gas twice my indicator the gas tank gauge does not show that the vehicle is empty it shows it's full and then I run out of gas on the side of the road almost get hit by cars trying to get to gas station to get more gas in the middle of traffic very dangerous have my daughter with me trying to push my vehicle out of the way so I don't get hit apparently it's a recall that says mine was done but it's not done because it's still having problems I am the third owner of mine so I think it was mislabeled as completed if that's the case then how do I know any of these recalls have been done properly;
2006 NISSAN TITAN Complaints
My vehicle, which I bought used with about 140,000 miles on it had cracked exhaust manifolds, which I replaced. Both were cracked and one actually fell to pieces when unbolted. One replacement cracked after about 15,000 miles, but was able to have it braised. Now, at about 180,000 miles they a spewing carbon monoxide into the cab again. This is a serious health and safety issue, and from checking Titan club web sites, it seems to be a widespread issue. I DO NOT DRIVE OFF ROAD OR SUBJECT THE TRUCK TO ABNORMAL DRIVING CONDITIONS. I appreciate your time and consideration. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);