Mercedes-Benz USA, LLC. is recalling certain 2020 GLE350

Mar 20, 2020 — Recall Campaign #20V172000

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2020 GLE350, GLE450 AND GLS450 vehicles. The seams on the rear crossmember may have been insufficiently welded. This may allow cracks to form when towing, possibly causing the rear crossmember to detach from the vehicle.

The recall was influenced by the manufacturer with about 224 units affected.

See recall notice

NHTSA Safety Recall Notice

20V172000

Manufacturer:	Mercedes-Benz USA, LLC
Recall date:	March 20, 2020
NHTSA Campaign #:	20V172000
Units affected:	224

Description:: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2020 GLE350, GLE450 AND GLS450 vehicles. The seams on the rear crossmember may have been insufficiently welded. This may allow cracks to form when towing, possibly causing the rear crossmember to detach from the vehicle.
Consequeces:: If the rear crossmember detaches from the vehicle, it can become a road hazard and increase the risk of a crash.
Corrective action:: MBUSA will notify owners, and dealers will replace the rear crossmember, free of charge. The recall began July 17, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020060013.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2020 MERCEDES-BENZ GLE 350 Complaints
I keep getting coolant level low. I add coolant fluid into the tank and the warning message comes up again. I see no leaks under my vehicle so not sure if there’s a leak inside the tank itself or air leak somewhere but I’ve gotten that warning message about 10 or more times. Also as im driving the blind spot sensor just randomly goes off without a car or anything being next to me.;
2020 MERCEDES-BENZ GLE 450 Complaints
My vehicle was in for a normal service to have the spark plugs replaced. However I was told that the engine wiring harness had become brittle (apparently a common and reoccurring problem with my vehicle) and would likely cause misfiring after changing spark plugs. This did indeed happen and if I didn’t elect to have the harness replaced, it would have put myself and my son in danger. It was a very costly repair (over $4000) for something that the vehicle manufacturer is at fault for.;
2020 MERCEDES-BENZ GLS 450 Complaints
AMENDMENT TO ACTIVE CASE 11723015. CRITICAL AIRBAG & SAFETY DEFECTS. This files a safety defect amendment to open case 11723015. Diagnostic scans confirm central data bus network collapse on VIN [XXX] has migrated into safety-critical occupant restraint and visibility modules, violating 49 U.S.C. § 30118. I. AIRBAG & RESTRAINT HAZARDS Scans from [XXX], document active faults: DTC U042782: "Implausible data received from Electronic Ignition Lock." The SRS module receives corrupted data from the failed ignition gateway, creating risk of airbag non-deployment. DTC B007A13: Passenger seatbelt pre-tensioner open circuit; occupants are unprotected against crash displacement. DTC B11FA4B: Active "Overtemperature" faults in heating elements indicate localized thermal short-circuit risk. II. HARDWARE DECAY Physical teardown confirmed structural oxidation on the central gateway motherboard and corroded connector pins. Modular swaps failed; network lock code U016887 returned within 8 months. Raw dealer records are available for federal inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);