2020 MERCEDES-BENZ GLE 450 Complaints

My vehicle was in for a normal service to have the spark plugs replaced. However I was told that the engine wiring harness had become brittle (apparently a common and reoccurring problem with my vehicle) and would likely cause misfiring after changing spark plugs. This did indeed happen and if I didn’t elect to have the harness replaced, it would have put myself and my son in danger. It was a very costly repair (over $4000) for something that the vehicle manufacturer is at fault for.

Engine compartment heat causes wiring harness insulation to melt and Electrical shorting while driving. Engine has lack of power and acceleration due to heat damage to the engine harness. Check Engine light came on. This is a potential fire risk and should be address by MBUSA. This is a know issue with this model. Car has only 36,000 miles

The air conditioning in my 2020 Mercedes-Benz GLE SUV has failed due to a refrigerant (freon) leak, leaving the system unable to cool and properly defrost the windshield. This is not an isolated issue—many other GLE owners have reported the same failure on forums and blogs, suggesting a widespread defect. NHTSA has already issued Recall No. 23V177000 (March 2023) for improperly installed A/C drain hoses in 2020–2021 GLE/GLS models, which created water intrusion, electrical shorts, fire risk, and failures of critical systems (eCall, unlocking, limp mode). In addition, a Mercedes-Benz Technical Bulletin dated August 5, 2024 (NHTSA MC-11000597-0001) specifically identifies evaporator refrigerant leaks as a frequent cause of A/C failure. Safety Concerns Loss of cabin cooling in hot weather poses risk of driver fatigue or heat-related illness. Defogging/defrosting may fail in humid conditions, creating visibility hazards. Prior related A/C defects have been tied to short circuits and electrical risks. Consumer Impact This defect has created significant hardship. The A/C failure occurred far earlier than expected for a premium vehicle, leaving me with high out-of-pocket repair estimates. The lack of cooling makes the car unsafe and uncomfortable to drive in hot weather, and the inability to properly defog/defrost windows compromises visibility. I purchased a Mercedes-Benz with the expectation of reliability and safety, and this known defect has undermined that trust. Requested Action Mercedes-Benz should cover the repair costs for affected vehicles, and NHTSA should investigate whether an expanded recall is necessary to include A/C evaporator refrigerant leaks as part of the broader HVAC system defect.

Both left and right headlamp/turn signal/marker light assemblies and control modules have been replaced. One under warranty in 2023, the second in 2025. Infotainment system displays error messages Messages may increase as assembly/control module becomes increasingly dysfunctional.

The rear shock absorbers have failed on my vehicle. The vehicle makes sounds when going over bumps in the road. There is an active recall on other GLE 2020 450 models but not my specific VIN. The vehicle has less then 30,000 miles on it before the shock absorbers went out.

Water intrusion. It rained, water leaked into driver seat floor. The water then made it to the electrical parts underneath the driver seat. This seems identical to the recall I am seeing online with the number: 23V-177

The contact owns a 2020 Mercedes-Benz GLE450. The contact stated while reversing, the rearview camera was inoperable. The message "Active parking Assist and Parktronic inoperative - See Operator's Manual" was displayed. The vehicle was taken to the dealer, where an unknown software update was performed; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that an unknown wiring harness had experienced an electrical short due to water entry underneath the floorboard. The dealer informed the contact that the parts were not available for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that parts were not available. The failure mileage was 26,994.

This is a known issue with GLE 450 48v batteries over heating and causing loss of power and all function to control the vehicle. , For an unknown reason my vehicle was not part of a recent recall and probably should have been. I experienced the issue today and escaped tragedy. My battery light came on, then off, then a bright red battery light came on across the dashboard…then all of a sudden, my car lost all power with no warning. All while driving on the freeway 394! Luckily traffic was light and I was able to coast halfway up an off ramp. Then I got an overheating message. Reports show all cars were recalled, however mine wasn’t part of the recall!! I would like an investigation to include all cars in the years and models not just some of them.

This past week, I went to the dealer for an intermittent engine light issue. The problem was minor and was fixed (faulty charcoal sensor). I asked to have my spark plugs replaced as well. The service department called me, and said that the engine harness is brittle and if they accessed.. it could break. This was not considered an immediate issue. Quote was $7300 to replace it. This seemed like a defect rather than an standard wear issue (even though I drive a lot, @ 170K highway miles). My car drives like new, and has had no major issues whatsover. In fact, it is only now that I need to have my rotors replaced. Had I not mentioned that I wanted new spark plugs, the issue would not have came up during the service. I hope that you can look into this, as other Mercedes GLE 450 owners make have the same issue as I. Please do not hesitate to reach out to me. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There were two incidents that had similar symptoms: one before the dealership said they fixed and one afterwards. The issue is that while driving I would get three warning, all at the same time: coolant too hot, 48v battery malfunction, shut the engine off. The first time it happened immediately after I turned on the vehicle and within 5 minutes of leaving a parking lot. The second time it happened after about 3 hours of driving at highway speeds. After the first time it happened dealership said they fixed the issue by upgrading the software (battery software?). Both times it happened on the highway. The first time on the uphill, and vehicle immediately shut off and could not make it up the ramp. The second time in the tunnel on the flat road, could not make it to the exit. Both times created extremely dangerous situation as I had no time to take the exit and vehicle shut off about 30 seconds after warning popped up. The second time in the tunnel was especially dangerous as there was no shoulder and i had to stop in the middle of the right lane as cars were going at 60 mph by me. I was really worried for myself and my family. I have to trust that Mercedes is capable of fixing the issue and providing a reliable vehicle I can depend on and trust for the safety of my family.