Daimler Vans USA, LLC. is recalling certain 2021 Mercedes-Benz Sprinter vehicles

Mar 08, 2022 — Recall Campaign #22V131000

Daimler Vans USA, LLC. (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter vehicles. The shim on the torsion bar was installed incorrectly during assembly.

The recall was influenced by the manufacturer with about 2,153 units affected.

See recall notice

NHTSA Safety Recall Notice

22V131000

Manufacturer:	Daimler Vans USA, LLC
Recall date:	March 08, 2022
NHTSA Campaign #:	22V131000
Units affected:	2,153

Description:: Daimler Vans USA, LLC. (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter vehicles. The shim on the torsion bar was installed incorrectly during assembly.
Consequeces:: An incorrectly assembled torsion bar may fail at the connection between the torsion bar and linkage, resulting in a loss of vehicle stability, and increasing the risk of a crash.
Corrective action:: Dealers will correct the position of the shim and replace the torsion bar linkages, free of charge. Owner notification letters were mailed August 16, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VADREH.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2021 MERCEDES-BENZ SPRINTER 1500 Complaints
The Distronic Cruise Control stops working and then will start working again several times on long trips. After research it appears if the radar doesn't detect anything in front of your vehicle for an hour it thinks it is inoperable and and shuts the Distronic Cruise Control off and it cannot be reengaged. If it detect a vehicles in front of you for four minutes or more it will reset the radar and your Distronic Cruise Control can be turned on again. This is dangerous as it requires you to follow closely behind another vehicle for at least four minutes to reset. Out west where I live there are a lot of road stretches' where you will have little to no traffic for over an hour. Mercedes needs to change this software bug and provide another method for it's radar check warning.;
2021 MERCEDES-BENZ SPRINTER 2500 Complaints
2020 Mercedes-Benz Sprinter. When the right turn signal is activated and the steering wheel is turned right, the windshield wipers activate unexpectedly. Diagnostic codes B230015 and B230615 are stored, indicating windshield wiper switch and wipe/wash malfunction. Concern appears related to the steering column multifunction switch/module. This affects driver visibility and steering-column control functions during turning/signaling.;
2021 MERCEDES-BENZ SPRINTER 3500 Complaints
The contact owns a 2021 Mercedes-Benz Sprinter 3500. The contact stated that while driving at an undisclosed speed, the message “Driver’s Side Air Bag Deactivated” was displayed. The vehicle was taken to a dealer, where it was diagnosed, and determined that the wiring harness needed to be rewired. The vehicle was repaired; however, the failure persisted, and the message was displayed. The vehicle was taken back to the dealer, where it was diagnosed with a voltage issue; however, the dealer stated that the vehicle was operating normally. The vehicle was not repaired. The vehicle was taken back to the dealer for another diagnostic test; however, the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The vehicle was taken to the dealer to be diagnosed, and the contact was informed that there was a wiring issue that needed to be corrected and that the air bag needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 8,000.;