Ford Motor Company is recalling certain 2025 Bronco Sport

Jan 31, 2025 — Recall Campaign #25V049000

Ford Motor Company (Ford) is recalling certain 2025 Bronco Sport, Escape, and Lincoln Corsair vehicles. The Instrument Panel Cluster (IPC) may not illuminate at startup or while driving. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 102, "Transmission shift lever sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 126, 108, 135, 138, 208, and 305.

The recall was influenced by the manufacturer with about 298 units affected.

See recall notice

NHTSA Safety Recall Notice

25V049000

Manufacturer:	Ford Motor Company
Recall date:	January 31, 2025
NHTSA Campaign #:	25V049000
Units affected:	298

Description:: Ford Motor Company (Ford) is recalling certain 2025 Bronco Sport, Escape, and Lincoln Corsair vehicles. The Instrument Panel Cluster (IPC) may not illuminate at startup or while driving. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays" and 102, "Transmission shift lever sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 126, 108, 135, 138, 208, and 305.
Consequeces:: An instrument panel display that fails to show critical safety information, such as the speedometer or warning lights, increases the risk of a crash.
Corrective action:: Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed February 17, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C02.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.

Affects the following:

2025 FORD BRONCO SPORT Complaints
Both front lower control arm ball joints on my 2025 Bronco Sport failed prematurely at approximately 13,000 miles. Upon removal, both ball studs showed heavy corrosion and clear evidence of water intrusion past the factory boot seals. One boot's upper metal retainer was visibly deformed, allowing water into the joint. This level of corrosion should not exist on a vehicle this new and indicates a defective component or seal, not normal wear. I have retained both failed parts and have photographs documenting the condition. This is the same component covered under Ford's active do-not-drive safety recall 26S36 (NHTSA campaign 26V-340) for front lower control arm ball joint defects on 2021–2026 Bronco Sport vehicles. My VIN is not included in that campaign, but I experienced failure of the identical safety-critical component. I am reporting this so NHTSA is aware the defect may extend beyond the current recall population. When I brought the vehicle to my local Ford dealer and requested inspection under the new vehicle warranty, the service department refused to inspect the vehicle at all, citing a 1.5-inch aftermarket leveling kit. No inspection was performed and no determination was made that the modification caused or contributed to the failure. A leveling kit does not cause water intrusion past a factory boot seal. Because the dealer refused service on a safety-critical component, I replaced both ball joints at my own expense to keep the vehicle safe to drive. I have opened a case with Ford Customer Relationship Center (case CXH-09202228-R9R8V5). No crash or injury occurred, but ball joint separation causes loss of steering control, and I believe this failure mode warrants investigation of vehicles outside the current recall scope.;
2025 FORD ESCAPE Complaints
Multiple computer related problems, including sensing objects that do not exist while using automated cruise control. Automatic braking engagement when car senses objects that do not exist both in the front and rear while driving. Rear sensor occupancy alert randomly triggered when it has been turned off, And when there is nobody in the back seat. GPS unable to locate signal even in wide open spaces, randomly drops service. Various climate control components read improperly, or do not display appropriately. Numerous morning messages both before and after incidents. The vehicle has been to Ford dealer, they have been unable to reproduce or determine what caused these faults.;
2025 LINCOLN CORSAIR Complaints
The contact owns a 2025 Lincoln Corsair. The contact stated that the turn signal noise was faint and could barely be heard by the driver. The contact stated that this failure could be a hazard to other drivers as the turn signal could be left on and the driver would not have any indication that the turn signal remained on. The vehicle was taken to the dealer and was informed that there was no remedy for the failure. The manufacturer was also notified of the failure and the representative acknowledged that the turn signal matter was a common issue reported to them from other owners. The contact was informed that there was a shift in how the digital audio was processed which caused the change in sound. The contact was again informed that there was no fix for the defect. The vehicle was not repaired. The failure mileage was 5.;