Thor Motor Coach is recalling certain 2023-2024 Twist

Nov 17, 2025 — Recall Campaign #25V791000

Thor Motor Coach (TMC) is recalling certain 2023-2024 Twist, Dazzle, 2023 Tranquility, Sanctuary, 2022-2024 Tellaro, Sequence, and 2024 Freedom Elite Van recreational vehicles. The solar panel mounting brackets may become loose or break allowing the solar panel to detach.

The recall was influenced by the Office of Defects Investigation with about 4,763 units affected.

See recall notice

NHTSA Safety Recall Notice

25V791000

Manufacturer:	Thor Motor Coach
Recall date:	November 17, 2025
NHTSA Campaign #:	25V791000
Units affected:	4,763

Description:: Thor Motor Coach (TMC) is recalling certain 2023-2024 Twist, Dazzle, 2023 Tranquility, Sanctuary, 2022-2024 Tellaro, Sequence, and 2024 Freedom Elite Van recreational vehicles. The solar panel mounting brackets may become loose or break allowing the solar panel to detach.
Consequeces:: A detached solar can become a road hazard for other vehicles and increasing the risk of a crash.
Corrective action:: Dealers will inspect and install missing washers, as necessary, free of charge. Owner notification letters were mailed January 12, 2026. Another notice will be sent once the remedy becomes available. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000336.

Affects the following:

2023 THOR MOTOR COACH SANCTUARY Complaints
Thor company of Indiana is the after market uplifter of a Ford Transit 2022. The Sancuary is teh model. The red power wire that connects from the secodnary altrnator in the enginne area runs along the inside f the front right tire to the chassi house battery in the back o the VAN. The power wire is incorrectly routed and the tire rubs up againsit it and rubs against the wire casuing damage and saftey issue. All of the 2023 models appear t be involved from a small sampling of owners on a facebook THOR sancuary owners forum. Thor refuses to issue a recall and refuses to facilitate the wire being replaced. They instead try to get you to take the van to the dealership and have it spliced instead. I would imagine there are some people that do not even know o the safety issue.;
2023 THOR MOTOR COACH TELLARO Complaints
First - van was in the shop 3+ times to fix the crash warning sensor. Eventually, they found a pinched wire - from installation. Told it was fixed - it's not. Next June 23/2025 - the van became completely engulfed in smoke while I was at the gas station. Many wires burned up. Here's a statement of what the dealer has found/done.These are major safety concerns. TMC CASE#: CAS-301574-X0Z3N3 REMOVE ACCESS COVERS, LOCATE BURNED WIRES UNDER JUMP SEAT. INSPECT FOR CAUSE OF FIRE. CHECK BREAKERS AND FUSES. FIND INVERTER INOP. FIND LOOSE CABLE CONNECTIONS UNDER COACH AT BUSS BARS. TIGHTEN CONNECTIONS, FIND BATTERIES DEAD. REMOVE FORWARD BATTERY AND CHARGE ON BENCH. FIND BOTH BATTERIES IN PROTECT MODE. CONNECT CHARGER, GET BATTERIES OUT OF PROTECT MODE. RECONNECT BATTERIES. BOTH 150A fuses have blown. DETERMINE A DIRECT SHORT TO GROUND SOMEWHERE IN 12V SYSTEM. REMOVE CABLES FROM BUSS BAR TO LOCATE SHORT. FIND SHORT GOES AWAY WHEN AUX ALTERNATOR IS DISCONNECTED. DISCONNECT CABLE @ ALTERNATOR. RECONNECT CABLES AND REPLACE 150A FUSES. GET 12V WORKING ON COACH. FIND INVERTER INOP. TROUBLESHOOT INVERTER. FIND MAIN 250A FUSE FOR INVERTER HAS A LOOSE NUT AND THE FUSE MELTED. REPLACE FUSE. CLEAN CABLE ENDS AND REATTACH CABLES. INVERTER TEST OK. TRACE LOOSE ROMEX BY SHORE CONNECTION. FIND ROMEX GOES UP TO THE CEILING AND CROSSES TO PS. FIND THE OTHER END. TRANSFER SWITCH. TRANSFER SWITCH NOT CONNECTED. TEST 12V SYSTEMS. RUN WATER HEATER AND FURNACE. FIND FURNACE OUTPUT HOSE EXTREMELY HOT AND FURNACE SHOWS W18H CODE. LOOK UP CODE, FIND CODE FOR BLOCKED HEAT REGISTER. NEXT STEP IS REMOVE THE FURNACE AND BENCH TEST. REMOVE EXHAUST PART FROM TRUMA HEATER. DISCONNECT HOSE. DISCONNECT WATER LINES. DRAIN WATER TANK. REMOVE TRUMA FROM COACH. CONNECT TO BATTERY AND LP CONNECT REMOTE. TEST ON BENCH;
2023 THOR MOTOR COACH TRANQUILITY Complaints
The grey water tank empty valve hangs close to the road without support. Mine fell off somewhere while driving cross country. This has happened to many owners and I believe it poses a highway safety hazard.;