CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH

Mar 28, 1995 — Recall Campaign #94V041000

CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.

The recall was influenced by the manufacturer with about 198,163 units affected.

See recall notice

NHTSA Safety Recall Notice

94V041000

Manufacturer:	General Motors, LLC
Recall date:	March 28, 1995
NHTSA Campaign #:	94V041000
Units affected:	198,163

Description:: CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequeces:: IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Corrective action:: DEALERS WILL INSPECT THE MANUFACTURING CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
Notes:: SYSTEM: WHEELS.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH KELSEY HAYES STEEL WHEELS; MODELS RPO PB6 14" AND RPO PG1 15".NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Affects the following:

1990 BUICK REGAL Complaints
ELECTRICAL SYSTEMS CONTROLLED BY SIGNAL LEVER DO NOT WORK EXCEPT BY HOLDING LEVER IN CERTAIN POSITIONS: I.E. BRAKE LIGHTS, SIGNAL LEVER L UP, TURN SIGNALS SWITCH LEVER UP, HIGH BEAMS NO GO ETC. ALL THE TIME.;
1990 CHEVROLET LUMINA Complaints
TL* THE CONTACT OWNS A 1990 CHEVROLET LUMINA. THE CONTACT STATED THAT THE FLOOR PANELS ON THE FRONT DRIVER AND PASSENGER SIDES WERE EXPOSED. ALSO, THE FRONT PASSENGER SIDE DOOR FAILED TO OPEN ON FROM OUTSIDE AND INSIDE THE VEHICLE. THE CONTACT HAD TO APPLY FORCE TO GET THE FRONT PASSENGER SIDE DOOR TO OPEN AND CLOSE. THE CONTACT ALSO INDICATED THAT ALL OF THE SEAT BELTS FAILED TO WORK EXCEPT THE REAR DRIVER SIDE SEAT BELT. ADDITIONALLY, THE VEHICLE STALLED MORE THAN ONCE AND THE STEERING WHEEL WAS EXTREMELY TIGHT UPON MAKING A TURN. THE VEHICLE WAS UNABLE TO BE SAFELY DRIVEN AND A KNOCKING NOISE WAS HEARD. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 91V005000 (SEAT BELTS) AND 90V054000 (SEAT BELTS). AN INDEPENDENT DEALER WAS NOTIFIED OF THE FAILURES AND INDICATED THAT THE VEHICLE NEEDED TO BE INSPECTED, BUT DID NOT CONFIRM THAT AN INSPECTION WAS COMPLETED BEFORE SELLING THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 211,591.;
1990 OLDSMOBILE CUTLASS Complaints
THE VEHICLE IS A 1990 OLDSMOBILE CUTLASS CIERA SL. I CHECKED BOX AS CHEVROLET AS OLDSMOBILE IS NOT AN OPTION ON THE DROP DOWN. FOUR NEW TIRES INSTALLED BETWEEN 12/31/13 AND 1/31/14, UNIROYAL AWP II TIGER PAWS SIZE P185/75R14. MANUFACTURER'S WEBSITE REPORTS THEY ?DO NOT CURRENTLY MANUFACTURE TIRES FITTING THIS VEHICLES SPECIFICATIONS.? ARE THE TIGER PAWS II P185/75R14 INSTALLED ON MY VEHICLE COUNTERFEIT TIRES? SINCE INSTALLING THESE TIRES, THE VEHICLE "SWAYS" WHEN DRIVING ON GROOVED INTERSTATE HIGHWAY PAVEMENT. *TR;
1990 PONTIAC GRAND PRIX Complaints
REAR SUBFRAME RETAINERS RUSTED OUT CAUSING ENGINE/TRANSAXLE TO DROP AND STEERING SHAFT TO SEPARATE CAUSING LOSS OF CONTROL WHERE THE VEHICLE ENDED UP IN THE ON COMING LANE OF TRAFFIC. THE RETAINERS HAVE BEEN REPLACED AT LEAST ONCE BEFORE. REPLACEMENT PARTS HAVE THE SAME DEFECT AS THE ORIGINAL PARTS. I DON'T BELIEVE THAT IS A SOLUTION. ONE GM DEALER (DON MILLER IN MADISON) DENIED ANY KNOWLEDGE OF A RECALL. ANOTHER GM DEALER SAID GM WILL OFFER A COUPLE HUNDRED DOLLARS AND TAKE THE CAR, BUT THERE IS NO REPAIR OPTION. YOUR PERSON I SPOKE WITH AT THE (888) PHONE NUMBER DIRECTED BE TO A GM (800) NUMBER WHO COULD NOT FIND ANY INFORMATION EVEN THOUGH I GAVE THEM THE RECALL NUMBER. IN ADDITION TO THE BOLTS AND RETAINERS THAT ARE "COVERED", THE RUBBER CUSHIONS AND TOP RETAINERS WERE UNABLE TO BE FOUND AND WILL REQUIRE REPLACEMENT. I HAVE ORDERED THE PARTS AT A COST OF ABOUT $110 AND A $60 TOW BILL PLUS ANY LABOR CHARGE I INCUR. LOOKING OVER THE NUMBER OF THESE FAILURES ON YOUR SITE, IT IS AMAZING TO ME THAT NO ACCIDENTS HAVE RESULTED THAT HAVE BEEN REPORTED. I WONDER HOW MANY HAVE OCCURRED AND THE CAUSE WAS NOT DISCOVERED. IT SEEMS TO ME THAT THE RECALL SHOULD BE CONTINUED TO INSPECT VEHICLES THAT HAVE BEEN "REPAIRED" WITH THE SAME DEFECTIVE PARTS. *TR;