BLUE BIRD VISION Recalls

Sep 13, 2006 – CERTAIN MY 2007 BLUE BIRD VISION SCHOOL BUSES EQUIPPED WITH AIR BRAKES MANUFACTURED FROM AUGUST 17 THROUGH SEPTEMBER 5, 2006. AN INCORRECT FITTING WAS DESIGNED INTO THE SUBASSEMBLY FOR THE REAR AXLE BRAKE VALVE MODULE. A STANDARD 90 DEGREE ELBOW WAS USED WHERE A 90 DEGREE CHECK VALVE SHOULD HAVE BEEN USED. THESE BUSES FAIL TO CONFORM TO THE BLEED DOWN REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "BRAKE SYSTEMS.

Jul 17, 2006 – CERTAIN 2004-2007 MY VISION SCHOOL BUSES MANUFACTURED BETWEEN AUGUST 5, 2003, AND JUNE 13, 2006, EQUIPPED WITH OPTION 40280-02 AMMETER SHUNT. THE POWER CABLE ORIGINALLY INSTALLED BETWEEN THE TOE BOARD AND THE SHUNT MAY BE TOO SHORT AND MAY BREAK DUE TO ENGINE VIBRATION.

Jun 08, 2006 – CERTAIN 2007 VISION SCHOOL BUSES EQUIPPED WITH BENDIX AIR BRAKES MANUFACTURED BETWEEN APRIL 7 AND MAY 26, 2006. THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SEAT, CAUSING INTERNAL AIR LEAKAGE. THIS CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Apr 11, 2006 – CERTAIN MY 2006 ALL AMERICAN SCHOOL AND TRANSIT BUSES AND 2006 CONVENTIONAL VISION SCHOOL BUSES MANUFACTURED BETWEEN JULY 7 AND NOVEMBER 8, 2005, EQUIPPED WITH RICON S AND K SERIES PLATFORM STYLE WHEELCHAIR LIFTS . THE VERTICAL SUPPORT ARMS FOR THE LIFTS WERE IMPROPERLY WELDED ALLOWING THE LIFT TO STOW IMPROPERLY.

Aug 31, 2005 – CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.

May 20, 2005 – CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

May 20, 2005 – CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

May 09, 2005 – CERTAIN MY 2006 BLUE BIRD ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 9 AND APRIL 15, 2005. SEAT SPACING IN FRONT OF THE SIDE EMERGENCY DOOR FLIP UP SEAT EXCEEDS THE MAXIMUM ALLOWED SPACING AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.

May 06, 2005 – CERTAIN BLUE BIRD MY 2004-2006 VISION SCHOOL BUSES EQUIPPED WITH HYDRAULIC BRAKES MANUFACTURED BETWEEN MARCH 24, 2003, AND APRIL 25, 2005. THE HYDRAULIC BRAKE DASH WARNING LIGHT WAS INCORRECTLY LABELED WITH THE CANADIAN VERSION WHICH USES SYMBOLS RATHER THAN WORDS AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

Mar 03, 2005 – CERTAIN 2004-2006 MY BLUE BIRD VISION CONVENTIONAL SCHOOL AND NON SCHOOL BUSES MAUNFACTURED FROM JUNE 12, 2003, THROUGH FEBRUARY 22, 2005. A SHORT CAN OCCUR IN THE CROSSING ARM CIRCUIT OR THE 8-WAY WARNING LIGHT CIRCUIT, CAUSING THE HEAVY DUTY TRANSISTOR W/BUILT IN CIRCUIT PROTECT TO TRIP RESULTING IN AN INADVERTENT ENGINE SHUTDOWN.