BLUE BIRD VISION Recalls

Jul 11, 2008 – THE HYDRAULIC BRAKE HOSES FROM THE MASTER CYLINDER TO THE CHASSIS FRAME MAY HAVE BEEN IMPROPERLY ROUTED OR RETAINED ON CERTAIN 2004 THROUGH 2009 MY BLUE BIRD VISION CONVENTIONAL SCHOOL AND TRANSIT BUSES MANUFACTURED FROM JANUARY 11, 2004 THROUGH APRIL 22, 2008.

Jul 10, 2008 – A PLUG ON THE OUTLET SIDE OF THE FUEL PUMP CAN CRACK ON CERTAIN 2008 AND 2009 MY BLUE BIRD ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED FROM MAY 23, 2007 THROUGH JULY 4, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES.

May 20, 2008 – BLUE BIRD IS RECALLING 23,464 MY 2005 THROUGH 2009 ALL AMERICAN AND VISION SCHOOL AND TRANSIT MODEL BUSES MANUFACTURED FROM JANUARY 22, 2004, AND MARCH 28, 2008, AND MY 2004 THROUGH 2007 ALL AMERICAN SCHOOL BUSES AND CONVENTIONAL MODEL SCHOOL BUSES MANUFACTURED FROM MARCH 6, 2003, THROUGH JUNE 16, 2006. THE RIVET PATTERN MAY BE INCORRECT IN SECTIONS OF THE REAR ROOF SHEET JOINT THAT ATTACHES TO THE REAR ROOF CAP. WITHOUT THE APPROPRIATE AMOUNT OF ROOF RIVETS, THE BUSES FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 221, "JOINT STRENGTH."

Sep 07, 2007 – CERTAIN 2008 BLUE BIRD VISION SCHOOL BUSES MANUFACTURED FROM JUNE 6 THROUGH SEPTEMBER 4, 2007. THE OIL FILL CAP MAY SEPARATE FROM THE OIL FILL TUBE ALLOWING ENGINE OIL TO BE EMITTED FROM THE TUBE. OIL COULD WET THE LEFT FRONT BRAKE SHOES/PADS RESULTING IN REDUCED BRAKING CAPACITY.

Aug 03, 2007 – CERTAIN BLUE BIRD MY 2008 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED BETWEEN JUNE 6 AND JULY 27, 2007. A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND CAUSE LOSS OF THROTTLE CONTROL AND EXCESSIVE SMOKE.

Jun 26, 2007 – CERTAIN MY 2007 AND 2008 BLUE BIRD VISION AND ALL AMERICAN SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 1, 2005, AND MAY 24, 2007, AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES. THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Jun 22, 2007 – CERTAIN BLUE BIRD MY 2004 THROUGH 2007 VISION SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 9, 2003, AND SEPTEMBER 21, 2006, EQUIPPED WITH PARKER SINGLE CHECK VAVLES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVENTUALLY BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE.

Feb 08, 2007 – CERTAIN BLUE BIRD 2007 AND 2008 VISION SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 9 AND OCTOBER 27, 2006. THE LIFT INNER BARRIER INTERLOCK SWITCH SYSTEM MAY NOT DETECT THE PRESENCE OF A PASSENGER ON THE INNER BARRIER AND ALLOW THE PLATFORM TO MOVE DOWN MORE THAN ONE INCH BELOW FLOOR LEVEL WHILE OCCUPIED WHICH DOES NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.

Jan 29, 2007 – CERTAIN 2007 AND 2008 MY BLUE BIRD VISION SCHOOL BUSES MANUFACTURED BETWEEN OCTOBER 16, 2006, AND JANUARY 18, 2007. CONTINUOUS RESETTING OF THE CIRCUIT BREAKER WHEN THE WIPER/WASHER IS OPERATING IN THE WASH/WIPE MODE MAY CAUSE FAILURE IN THE WIRING CIRCUIT RESULTING IN POWER BEING APPLIED TO THE GROUND WHICH COULD CAUSE THE CIRCUIT BREAKER TO OVERHEAT AND FAIL RESULTING IN A STALLED WIPER.

Dec 06, 2006 – CERTAIN 2008 BLUE BIRD VISION SCHOOL BUSES BUILT FROM OCTOBER 23 THROUGH NOVEMBER 21, 2006. A TEMPORARY BOLT WAS USED TO SECURE THE STEERING WHEEL DURING THE MANUFACTURING PROCESS. THE TEMPORARY BOLT WAS TO BE REMOVED AND REPLACED WITH A PERMANENT BOLT WITH A LOCK COATING DURING THE FINAL ASSEMBLY STAGE. THE TEMPORARY BOLT WAS NOT REMOVED AND REPLACED ON THE SUBJECT UNITS, BUT INSTEAD THE BOLT WAS REUSED.