CHEVROLET Recalls

Oct 04, 2007 – ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.

Sep 27, 2007 – ON CERTAIN CUSTOM LIVING QUARTER OR LOUNGE TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Aug 28, 2007 – ON CERTAIN STRAIGHT TOWING OR NON-TOWING TRUCKS EQUIPPED WITH BENDIX AIR BRAKES, THE AIR BRAKE PARK CONTROL VALVE MAY DEVELOP EITHER AN INTERNAL AIR LEAK OR AN AIR RESTRICTION. THE PARK BRAKE MAY NOT RELEASE OR MAY RELEASE ONLY PARTIALLY.

Aug 28, 2007 – CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Aug 08, 2007 – ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Aug 07, 2007 – CERTAIN VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." WHEN THE BRAKES ARE APPLIED, THE STOP LAMPS WILL ILLUMINATE. WHEN THE BRAKE PEDAL IS RELEASED, THE STOP LAMPS ARE NO LONGER ILLUMINATED BUT THE REAR BRAKES MAY STILL BE APPLIED. THE BRAKE MAY RELEASE AFTER A FEW SECONDS OR AFTER THE NEXT FIRM BRAKE PEDAL APPLICATION.

Aug 07, 2007 – CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." IN THESE VEHICLES, THE RIGHT FRONT PASSENGER SEAT IS BUILT WITH A PASSENGER SENSING SYSTEM. WHEN TESTED WITH A REPRESENTATIVE UNRESTRAINED SMALL ADULT, THE SYSTEM IS REQUIRED TO TURN THE RIGHT FRONT PASSENGER'S FRONTAL AIRBAG ON. AN ERROR IN THE SEAT SENSOR CALIBRATION CAN CAUSE IT TO FAIL THIS TEST. IN ADDITION, THIS CONDITION CAN PREVENT THE AIRBAG FROM TURNING OFF WHEN THE SEAT IS OCCUPIED BY A SMALL CHILD.

Jul 20, 2007 – CERTAIN VEHICLES LOCATED IN GUAM AND SAIPAN WERE BUILT WITH A SEAT BELT BUCKLE WITH AN IMPROPER ULTRASONIC WELD OF THE SPRING RIB AND FIXATION RIB OF BUCKLE UNDERCOVER IN BOTH FRONT SEAT BELTS. A SPRING RIB OR FIXATION RIB COULD BREAK AND REMAIN INSIDE THE BUCKLE, AND THE SEAT BELT TONGUE MAY NOT BE INSERTED INTO THE BUCKLE, OR THE PUSH BUTTON MAY BECOME STUCK, RESULTING IN AN OCCUPANT NOT BEING ABLE TO UNLATCH THE BUCKLE.

Jun 13, 2007 – CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD. THE SAME PRIMER MAY HAVE ALSO BEEN APPLIED TO THE LIFTGATE GLASS AND THE SIDE STATIONARY GLASS.

Jun 04, 2007 – ON CERTAIN VEHICLES EQUIPPED WITH SERIES 0307, HR0307A, HR0307B, HR1000A OR HR1500HB HY--RAIL GUIDE WHEEL EQUIPMENT, THESE STEERING STOPS MAY NOT BE CORRECTLY INSTALLED.