FLEETWOOD BOUNDER Recalls

Jul 20, 2004 – CERTAIN MOTOR HOMES EQUIPPED WITH DRAW TITE HITCH RECEIVERS MAY BE MISSING ONE OR MORE WELDS BETWEEN THE HITCH RECEIVER BOX AND THE BOTTOM SUPPORT PLATE.

Feb 18, 2004 – ON CERTAIN MOTOR HOMES EQUIPPED WITH POLAR MACH AND POLAR CUB AIR CONDITIONERS, THE SOLAR PANEL RUBBER WELL NUTS COULD FRACTURE THE PLASTIC SHROUD IN THE IMMEDIATE AREA OF THE ATTACHMENT HOLE.

Nov 04, 2003 – ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Sep 16, 2003 – ON CERTAIN MOTORHOMES BUILT ON WORKHORSE CHASSIS, THE HYDRAULIC HOSE OPERATING THE LEVELING JACK SYSTEM WAS ROUTED SO IT PLACES THE HOSE TOO CLOSE TO THE ENGINE EXHAUST. THE HOT EXHAUST CAN CAUSE THE HYDRAULIC HOSE TO MELT OR ABRADE, RELEASING HYDRAULIC FLUID.

Mar 04, 2003 – CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Jul 27, 2000 – VEHICLE DESCRIPTION: MOTOR HOMES. THE POWER STEERING GEAR BOX HYDRAULIC LINES ARE ROUTED TOO CLOSE TO A SHARP EDGE. THIS CAN CAUSE THE LINES TO RUPTURE AND RESULT IN A HYDRAULIC FLUID LEAK.

Jan 26, 1999 – VEHICLE DESCRIPTION: CLASS A MOTOR HOMES. THESE MOTOR HOMES, WHEN FULLY EQUIPPED AND LOADED WITH TYPICAL CARGO, WILL EXPERIENCE AN OVERLOADED CONDITION ON THE REAR AXLE.

Jun 26, 1998 – VEHICLE DESCRIPTION: MOTOR HOMES. THE DRIVER'S AND PASSENGER'S SIDE WINDOWS DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 205, "GLAZING MATERIALS," FOR AN ACCEPTABLE LEVEL OF TINT.

Oct 07, 1997 – VEHICLE DESCRIPTION: CLASS A MOTOR HOMES. THE HYDRAULIC HOSES WHICH OPERATE THE LEVELING JACK SYSTEM IS ROUTED TOO CLOSE TO THE ENGINE EXHAUST MANIFOLD CAUSING THE HOSE TO MELT, RELEASING HYDRAULIC FLUID.

Nov 22, 1996 – THE E-Z SLIDE-OUT ROOM CAN OPERATE UNEXPECTEDLY. WATER CAN CAUSE AN ELECTRICAL SHORT IN THE SLIDE-OUT ROOM CONTROL RELAY.