FREIGHTLINER MT45 Recalls

Feb 16, 2018 – Daimler Trucks North America LLC (DTNA) is recalling certain 2018 Freightliner MT45G and MT55G custom chassis built with certain uStart Ultra Capacitors. The bracket that secures the capacitor to the battery tray may damage the capacitor and allow water to enter the capacitor, causing corrosion or a possible electrical short.

Dec 20, 2013 – Daimler Trucks North America (DTNA) is recalling certain model year 2014 Freightliner Custom Chassis MT45, MT55 and MBC Chassis manufactured September 24, 2013, through November 7, 2013. In the affected vehicles, due to an incorrect calibration, the speedometer may display a speed lower than the vehicle is actually traveling.

Dec 16, 2013 – Daimler Trucks North America (DTNA) is recalling certain model year 2009-2014 model year Freightliner Business Class M2 and Freightliner Custom Chassis MT45 and MT55 chassis manufactured August 27, 2008, through December 10, 2013 and equipped with Eaton hybrid automated transmissions. The software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.

Mar 04, 2013 – Daimler Trucks North America (DTNA) is recalling certain model year 2011-2014 MT45G and MT55G van chassis manufactured from February 15, 2010, through September 3, 2013. These vehicles have gasoline fuel tanks that may experience cracks in the welds and tank material.

Oct 08, 2010 – DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 FREIGHTLINER BUSINESS CLASS M2, CUSTOM CHASSIS MT45, S2 CHASSIS, AND STERING ACTERRA VEHICLES MANUFACTURED FROM OCTOBER 5, 2006, THROUGH MAY 24, 2010, EQUIPPED WITH EPA 2007 MBE 900 DETROIT DIESEL ENGINES. ENGINE SOFTWARE MAY NOT REACT PROPERLY TO CERTAIN AFTERMARKET TREATMENT DEVICE FAULT CODES. THE SOFTWARE MAY UNNECESSARILY SHUTDOWN A VEHICLE OR MAY FAIL TO SHUTDOWN A VEHICLE WITH AN AFTERMARKET DEVICE OVER-TEMP FAULT.

Nov 19, 2009 – CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Oct 05, 2005 – CERTAIN 2004 AND 2005 FREIGHTLINER VAN, MOTOR HOME, SHUTTLE BUS, AND SCHOOL BUS CHASSIS MANUFACTURED BETWEEN JANUARY 2004 AND MAY 2005. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE WEAR OF THE PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL LIFT PUMP FAILURE AND IN SOME CASES MAY CAUSE AN ENGINE STALL CONDITION.

Sep 17, 2001 – VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.

Sep 20, 1999 – VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE THROTTLE CABLE CAN BIND DUE TO MISALIGNMENT WITH THE FUEL PUMP ASSEMBLY.

Apr 12, 1999 – VEHICLE DESCRIPTION: STEP VANS EQUIPPED WITH SPICER 6,000 OR 8,000 LB. FRONT STEER AXLES. THE TIE ROD END CAN PULL OUTBOARD AND SEPARATE FROM THE TIE ROD TUBE DUE TO IMPROPER THREAD ENGAGEMENT BETWEEN THE MALE TIE ROD END AND THE FEMALE TUBE.