HONDA Recalls

Aug 15, 2007 – ON CERTAIN MOTORCYCLES, THE FRONT FAIRING SUB-HARNESS (SECTION OF THE WIRING HARNESS) TRANSFERS THE ELECTRICAL GROUNDING LOAD OF THE HEADLIGHTS, FRONT TURN SIGNALS, INSTRUMENT PANEL, AND VARIOUS RELAYS TO THE MAIN WIRING HARNESS VIA AN 18-PIN CONNECTOR. UNDER CERTAIN CONDITIONS, THE GROUND WIRE TERMINALS INSIDE THE CONNECTOR CAN OVERHEAT, RESULTING IN MELTING OF THE CONNECTOR AND A LOSS OF POWER TO VARIOUS CIRCUITS.

May 17, 2007 – CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 317-1131L-AS, 317-1131R-AS, 317-1131L-US, AND 317-1131R-US, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION A SLIGHT DISTORTION OF THE BEZEL CHANGED THE LUMINOUS INTENSITY OF THE TURN SIGNAL. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Mar 21, 2007 – ON CERTAIN MOTORCYCLES, THE CRANKCASE BREATHER SEPARATOR MAY BE DEFECTED. DURING THE MOLDING PROCESS, THE BREATHER PASSAGE MAY HAVE BEEN BLOCKED BY A THIN LAYER OF THE INJECTED PLASTIC MATERIAL. THIS BLOCKAGE WILL CREATE A BUILD-UP OF PRESSURE INSIDE THE CRANKCASE AND MAY CAUSE THE LEFT SIDE ENGINE SEAL TO BE PUSHED OUT OF POSITION AND AN OIL LEAK WILL OCCUR.

Mar 14, 2007 – ON CERTAIN VEHICLES, A COIL WIRE INSIDE THE FUEL PUMP RELAY MAY BREAK, CAUSING THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.

Feb 08, 2007 – ON CERTAIN PASSENGER VEHICLES, CERTAIN PARTS OF THE INTEGRATED MOTOR ASSIST (IMA) SYSTEM ARE LOCATED UNDER A METAL COVER BEHIND THE REAR SEAT-BACK. OVER TIME THE WEIGHT OF REAR SEAT PASSENGERS MAY CAUSE THE METAL COVER TO COME INTO CONTACT WITH A RUBBER CAP COVERING AN ELECTRICAL TERMINAL. THE RUBBER CAP MAY GET PINCHED, EXPOSING THE ELECTRICAL TERMINAL.

Jan 16, 2007 – CERTAIN TYC HEADLAMP ASSEMBLIES P/NS 20-6361-00 AND 20-6362-00 SOLD AS AFTERMARKET EQUIPMENT FOR 2003-2006 HONDA ACCORD PASSENGER VEHICLES. THE PHOTMETRIC WERE MISALIGNED WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Jan 03, 2007 – ON CERTAIN VEHICLES, THE SEAT POSITION SENSOR (SPS) DETECTS THE DRIVER'S SEATING POSITION AND ADJUSTS THE AIR BAG INFLATION PRESSURE ACCORDINGLY. THE WIRING HARNESS FOR THE SPS WAS ATTACHED TO THE SEAT FRAME IN THE WRONG LOCATION AND MAY HAVE BEEN OVER TIGHTENED. THE SENSOR WIRE MAY BREAK AND CAUSE THE AIR BAG WARNING LIGHT TO BE ILLUMINATED, AND THE SPS TO FAIL.

Nov 20, 2006 – CERTAIN HONDA ACCESSORY TRAILER HITCHES, P/N 08L92-STK-200, MANUFACTURED BETWEEN JUNE 26 AND JULY 8, 2006, AND SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 2007 MODEL YEAR ACURA RDX VEHICLES. THE HITCHES MAY HAVE BEEN IMPROPERLY WELDED DURING INSTALLATION.

Aug 31, 2006 – ON CERTAIN 2-DOOR PASSENGER VEHICLES, THE REAR WINDSHIELD OR REAR QUARTER GLASS PANELS DO NOT PROPERLY ADHERE TO THE BODY OF THE CAR DUE TO IMPROPER WINDOW OPENING PREPARATION.

Jul 26, 2006 – ON CERTAIN PASSENGER VEHICLES AND MOTORCYCLES, THE OWNER'S MANUALS CONTAIN INCORRECT CONTACT INFORMATION FOR THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S (NHTSA) VEHICLE SAFETY HOTLINE.