BRAKE PARTS Complaints

1. NO BRAKING WHEN START CADILLAC SRX 2008 AFTER SITTING FOR MORE THAN 3 HOURS. JUNE 2009 2. TOOK TO DEALER-THEY REPLACED PADS AND TOLD ME IT WAS REPAIRED. JUNE 2009 3. NEXT DAY, NO BRAKES AGAIN, RETURNED TO DEALER AND THEY INFORMED THAT A BRAKE PUMP NEEDED TO BE PUT ON THE VEHICLE DUE TO MANUFACTURING FLAW. HAD THEM ORDER PART, BUT DID NOT COME IN PRIOR TO RETURNING TO HOME TOWN. REFUSED TO FORWARD PART TO MY DEALER.JUNE 2009 4. TOOK CAR TO MY DEALER AND WAS TOLD NO SUCH PART EXISTED. JULY 2009 5. TOOK CAR BACK 3 TIMES TO MY DEALER AND WAS FINALLY TOLD THERE WAS A PART TO ORDER TO FIX THE PROBLEM. SEPT 2009 6. GM OFFERED EXTENDED WARRANTY FOR BRAKE SYSTEM AND COMPONENTS. ACCEPTED BECAUSE THOUGHT PROBLEM TAKEN CARE OF. OCTOBER 2009 7. JUNE 2010 PROBLEM RECURRED. 8. JULY 2010 WAS TOLD PROBLEM WAS TAKEN CARE OF. WENT TO PICK UP CAR. TEST DROVE WITH TECHNICIAN AND BRAKES STILL DID NOT WORK PROPERLY EVEN WITH NEW PUMP AND OTHER PARTS THEY HAD INSTALLED. HAVE BEEN WITHOUT CAR OVER A MONTH AND STILL NOT WORKING. THE PROBLEM IS INTERMITTENT AND ONLY OCCURS ON INITIAL START AFTER SITTING FOR SEVERAL HOURS. SO FAR HAVE RUN OVER CURB AT OFFICE NEARLY HITTING AN ONCOMING CAR, ALMOST RAN OVER MY GRANDSON WHEN PULLING OUT OF GARAGE AND ALMOST HIT A CAR IN PARKING LOT DUE TO NON STOPPING OF VEHICLE. THE BRAKES ARE UNRELIABLE. THERE SHOULD BE A RECALL ON THE VEHICLE. GM DOES NOT SEEM TO BE ABLE TO REPAIR THE PROBLEM AFTER OVER A YEAR. *TR

I HAVE A 2006 FORD EXPEDITION AND MY WIFE ALMOST LOST CONTROL AND HIT A CAR WHEN THE BRAKES WENT TO THE FLOOR. THE VEHICLE HAS HAD "SPONGY BRAKES" SINCE I BOUGHT IT AND HAD IT TO THE DEALER TWICE. THERE IS A TSB TO REPLACE THE FRONT CALIPER/ROTOR AND PADS AND FORD DID THIS BUT IT STILL FEELS SPONGY AND IS NOW LEAKING FLUID. THIS HAS BEEN AN ISSUE ON MANY EXPEDITIONS AND SHOULD HAVE BEEN A RECALL RATHER THAN A TSB. THIS IS AN INCREDIBLY DANGEROUS SITUATION WHEN THE BRAKES FAIL. I KNOW I HAVE HAD INSTANCES WHERE I LITERALLY NEED TO STAND ON THE BRAKES TO GET THE VEHICLE TO STOP. *TR

THE U-SPRING HOLDING THE REAR BRAKE DRUMS TOGETHER RUSTED THROUGH AND BROKE INTO TWO PIECES. THE DEALERSHIP REPLACED BOTH OF THE REAR BRAKE DRUM KITS AT A PRICE COST TO ME OF $117.40. *TR

I HAVE A CHRYSLER TOWN AND COUNTRY 2008 MINIVAN. I HAVE HAD BRAKE AND ROTOR PROBLEMS BEGINNING AFTER ONE YEAR. I HAD FRONT BRAKES PADS REPLACED AND ROTORS RESURFACED AT 11,300 MILES. I DID NOT TRUST CHRYSLER TO DO IT. AT 20,740 MILES, I HAD TO DO REPLACE FRONT BRAKES AND ROTORS AGAIN. AT 22,000 MILES, THE CAR SHOOK LIKE A CARNIVAL RIDE WHEN I APPLIED BRAKES. REAR ROTORS WERE WARPED AND THEY WERE REPLACED ALONG WITH THE CALIPER SLIDES. ON THE REAR RIGHT, THE SLIDE PIN BOLT WAS DAMAGED. WITHIN FOUR MONTHS, AT 24,700 MILES, THE REAR BRAKES WERE REPLACED AGAIN. AT 24,947, THE AC HOSE WAS RUPTURED. FIVE WEEKS LATER, AT 26, 869 MILES, I HAD ALL BRAKES AND ROTORS REPLACED AGAIN. THIS TIME WE PUT IN CERAMIC BRAKE PADS AND BETTER QUALITY ROTORS. THE SERVICE MAN NOTIFIED ME THAT THE FRONT BRAKE ROTOR WAS VERY OVERHEATED WITH BLUE SCORCH MARKS. HE SAID A POSSIBLE FIRE COULD HAVE HAPPENED DUE TO BRAKE CALIPER OR COLLAPSED BRAKE HOSE ISSUE. WE HATE THIS VAN. IT IS TWO YEARS OLD AND HAS COST US A FORTUNE. CHRYSLER SHOULD REIMBURSE US FOR ALL THE BRAKES AND ROTORS. *TR

THIS WAS A FORD 1999 WINDSTAR RECALL ON THE ABS SYSTEM. THE RECALL STATED THAT A FIRE MAY OCCUR IN CONNECTION WITH THE ABS. I TOOK THE CAR IN, HOWEVER THE BRAKE FLUID LEAK INSIDE THE CAR HAS GOTTEN WORSE. FROM TIME TO TIME THE CAR SMOKES UP, AND THERE IS A BURNING SMELL. THE ABS LIGHT CONTINUES TO COME ON. MY FEAR IS THAT THIS IS STILL A HAZARD WITH ALL THE FLAMMABLE BRAKE FLUID IN THE CAR. I LOOKED IT UP AND OTHERS HAVE CALLED THIS PROBLEM "BRAKING DISTANCE SUDDENLY INCREASED SERVICE BRAKES, HYDRAULIC". BRAKE FLUID LEAKING INTO THE CAR. THIS SEEMS TO OCCUR CONSTANTLY. I HAVE CLEANED MY CAR WITH THE THOUGHT THAT I SPILLED OIL, HOWEVER AFTER READING UP FOUND OUT THAT THIS WAS THE PROBLEM. WHEN I TOOK IT IN FOR THE RECALL, THIS WAS NOT MENTIONED AT ALL TO ME BY THE FORD DEALER. I WILL BE TAKING IT TO THE DEALER THAT FIXED IT TO SEE WHAT THEY WILL DO OR SAY. I GUESS I AM WONDERING IF THERE IS ANYTHING ELSE TO DO. *TR

MULTIPLE BRAKE FAILURES WITH MY 2005 NISSAN ARMADA. NISSAN MOTOR AMERICA IS WELL AWARE OF THE SERIOUS SAFETY DEFECTS IN MY VEHICLE BUT WILL NOT HONOR THE 2 TIMES OF A MAJOR SYSTEM FAILURE TO REPLACE THE VEHICLE. THIS IS THE 4TH TIME I HAVE HAD A MAJOR BRAKE FAILURE ON THE VEHICLE INCLUDING ITS SYSTEMS AND COMPUTER COMPONENTS. PARTS HAVE BEEN REPLACED IN MY VEHICLE 4 TIMES. THE LAST TIME, I WAS ASSURED BY A DTC FROM CALIFORNIA WHO FLEW UP TO WA WHO AUTHORIZED THE REPLACEMENT OF THE ENTIRE BRAKING SYSTEM WHICH FAILED AGAIN "IT WOULD NEVER HAPPEN AGAIN". MULTIPLE FAILURES ON THE DIAGNOSTICS REVEALED CODES WHICH WAS AGAIN AUTHORIZED THE REPLACEMENTS OF PARTS FROM A CONSUMER AFFAIRS REGIONAL MANAGER: CODES: VEHICLE DCT C11110-CONTROLLER FAILURE, P1832 TCS OP SIGNAL, P1831-VDC OP SIGNAL, P1828 -LINE PRES. IN SHORT, MASTER VACCUM, MASTER CYLINDER, ABS CONTROL UNIT, ALL WERE REPLACED AGAIN. NISSAN FP NUMBERS: 47660-ZQ21B ACTUATOR ASSY. 47210-ZC01C MASTER VAC ASSY, 46010-7S20A CYL BRAKE MASTER, WIRING CONNECTORS, BRAKE FLUID...ETC, ETC. THIS IS ANOTHER FAILURE ATTEMPT FOR NISSAN TO SKIRT THE SERIOUSNESS OF THIS ISSUES OF MY VEHICLE AND HUNDREDS OF OTHERS IF NOT THOUSANDS. SERVICE ADVISOR FROM TOWN NISSAN IN WENATCHEE MENTIONED THAT THE ROTORS HAS BEEN TURNED. WORK NOT PERFORMED. LIED TO ME AS A CUSTOMER. NOW I HAVE MAJOR BREAK FADE FROM MY VEHICLE BEING TESTED FROM THE DEALERSHIP TO TRY AND DUPLICATE THE FAILURE INITIALLY AND ROAD TESTING IT FOR PROPER FUNCTION. THE FIRST 3 BRAKE FAILURES OCCURRED WITHIN THE FIRST 2 YEARS OF THE VEHICLES LIFE. 3200 MILES - ROTORS FAILED, 5800 MILES-MAJOR BRAKE FAILURE ALL COMPONENTS REPLACED. 13,000 MILES-ANOTHER MAJOR BRAKE FAILURE, PARTS REPLACED AGAIN, 22,000 MILES ROTORS WARPED & REPLACED. 28,000 MILES, BRAKE FAILURE AGAIN, MAJOR SYSTEMS REPLACED AGAIN. 49,000 MILES AGAIN BRAKES FAILED. MAJOR SYSTEMS REPLACED. WHEN WILL NISSAN LISTEN? AFTER A DEATH IN A SCHOOL ZONE? CROSSWALK? MYSELF? REPLACEMENT OF PARTS IS A POOR ATTEMPT FOR NISSAN. *TR

I HAVE A 2008 HONDA ACCORD AND JUST ROLLED OVER 41,000 MILES. I STARTED TO HEAR THE METAL ON METAL COMING FROM MY REAR WHEELS. THIS IS MY 3RD ACCORD SO I KNOW IT IS BRAKES RELATED. 41,000 MILE WOULD BE OK EXCEPT I ALSO HAD THE BRAKES REPLACED AT 21,000 MILES. I WAS LUCK THAT MY DEALERSHIP COVERED THE 1ST SET UNDER WARRANTY BUT NOW THAT I AM NO LONGER COVERED UNDER THE WARRANTY I AM GOING TO HAVE TO PAY. ON BOTH OF MY PREVIOUS ACCORDS I ONLY REPLACED THE BRAKES ONCE IN OVER 100,000 MILES. SOMETHING IS NOT RIGHT. *TR

I HAVE ATTEMPTED TO GET MY BRAKES REPAIRED ON A 2008 AUDI Q7. I HAVE TAKEN IT TO TWO DIFFERENT SERVICE CENTERS WITH 2 VISITS TO EACH ONE. NONE OF THEM HAVE FIXED THE PROBLEMS COMPLETELY. *TR

WE PURCHASED A BRAND NEW 2008 CHRYSLER TOWN & COUNTRY MINI VAN JUST BEFORE NOV 25, 2008. A MONTH AGO AT 17,000 WE HAD TO PUT ON ALL NEW(FRONT AND BACK) BRAKE PADS AND ROTORS! THIS CAR IS NOT DRIVEN HARD OR FUNNY, WE DO NOT RIDE OUR BRAKES. SINCE CHRYSLER DOES NOT COVER BRAKES AFTER 12,000 MILES SO WE HAD THEM REPAIRED AT THE OILWORKS, BY A MAN WE TRUST. THE COST WAS $400, YESTERDAY, 300 MILES AFTER THE NEW BRAKES WERE INSTALLED WE HAD TO HAVE NEW ROTORS INSTALLED AGAIN! WE WERE NOT CHARGED FOR THE SECOND ROTORS BUT WERE TOLD THAT THERE WAS SO MUCH BRAKE DUST THE PADS WERE ALREADY WEARING! I STARTED LOOKING ONLINE AND FOUND THAT THERE ARE LITERALLY THOUSANDS OF PEOPLE WITH THE SAME COMPLAINT ABOUT ABNORMAL BRAKE WEAR ON THE 2008 CHRYSLER TOWN & COUNTRY VANS. WE PAID ABOUT $30,000 FOR THIS VEHICLE AND WE MAINTAIN IT PROPERLY. I THINK CHRYSLER SHOULD HAVE TO STAND UP FOR THE LOUSY BRAKES THEY ARE INSTALLING ON THESE CARS. AND COME UP WITH A BRAKE PRODUCT THAT WORKS! *TR

I HAVE 5000 MILES ON MY 09 COBALT SS AND I TOOK MY CAR IN TO PUT STAGE 1 ON AND LOOK AT MY BRAKES BECAUSE THEY ALREADY HAD GROOVES IN THEM. THERE NEEDS TO BE A HIGHER QUALITY BRAKE AND ROTOR PUT ON THE REARS. *TR