TOYO TIRES Complaints

TIRE FALLING APART AND FLAKING INCLUDING PREMATURE WEARING ON FACTORY OEM TOYO OPEN COUNTRY 245-55X19 A20 TIRES WHICH WERE ON MY 2008 TOYOTA HIGHLANDER PURCHASE BRAND NEW ON JUL 2008. APPROXIMATE CURRENT MILEAGE IS 20,195. ALL TIRES ARE SHOWING THE SAME ABNORMAL WEAR AS VERIFIED BY TOYOTA DEALER. THERE ARE NUMEROUS ONLINE COMPLAINTS OF SIMILAR OWNERS WITH PICTURES OF THE UNUSUAL WEARING. MINE ARE WORSE THAN ARE DESCRIBED AS CONCURRED BY TOYOTA SERVICE ADVISORS. *TR

TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER EQUIPPED WITH TOYO OPEN COUNTRY AT TIRES, SIZE P245/55R19. THE CONTACT STATED THAT ALL FOUR TIRES WERE CHIPPING AWAY ON THE SHOULDER OF THE INSIDE. WHILE DRIVIGN 35 MPH, THE TIRE PRESSURE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE TIRES WERE INSPECTED AND THE CHIPPING WAS DISCOVERED. THE CONTACT CALLED THE TIRE MANUFACTURER WHO ADVISED HER TO TAKE THE VEHICLE TO THEIR TIRE DEALER. THE CONTACT DID NOT FEEL COMFORTABLE DRIVING THE VEHICLE TO THE DEALER WITH THE DEFECTIVE TIRES. THE TIRES HAD NOT BEEN REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 28,000.

TL*THE CONTACT OWNS A 2010 MAZDA5 WITH TOYO M122 205/50P TIRES. THE CONTACT STATED THAT THE DRIVERS REAR AND FRONT TIRES HAVE FAILED. THE DRIVER SIDE FRONT TIRE DEVELOPED A LARGE BLISTER ON THE SIDEWALL. THE DRIVER SIDE REAR TEAR HAD A SCREW IN THE SIDEWALL. THE OWNER WAS NOT SURE IF THE FAILURE WAS CAUSED BY THE TIRES OR THE WHEEL DESIGN OF THE VEHICLE. MAZDA INFORMED HIM THAT THE DEFECT WAS CAUSED BY ROAD HAZARDS. THE TIRES WERE NOT REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 1228.

GREETINGS. I AM WRITING TO YOU REGARDING MY 2008 HIGHLANDER SPORT, SERIAL NUMBER [XXX]. SPECIFICALLY, I AM WRITING ABOUT THE OEM TIRES, TOYO OPEN COUNTRY, DOT CXHH, DK82508. AS OF TODAY, I HAVE 23, 897 MILES ON THE VEHICLE; AND THE TIRES ARE COMPLETELY WORN OUT TO A POINT BELOW THE WEAR BARS, WHICH INDICATES THAT THEY MUST BE REPLACED NOW. WHEN I PURCHASED THE VEHICLE IN OCTOBER 2008, I PURCHASED THE TOYOTA MAINTENANCE PROGRAM, SO THE TIRES ARE ROTATED AND BALANCED (IF NECESSARY) EVERY 5,000 MILES WHEN I ALSO CHANGE THE OIL. I AM A 46 YEAR OLD FATHER OF THREE SMALL CHILDREN, WITH NO MOVING VIOLATIONS, TICKETS OR ACCIDENTS. I TELL YOU THIS ABOUT MY LIFE TO INDICATE THE TYPE OF CONSERVATIVE DRIVER THAT I AM. I HAVE CONDUCTED EXTENSIVE RESEARCH ONLINE AND HAVE IDENTIFIED THE LOWEST PRICE FOR A SET OF FOUR TIRES AT $759.88, WHICH WILL ACTUALLY MORE EXPENSIVE DURING THE BUY DUE TO THE TPMS SYSTEM, THE NECESSITY FOR AN ALIGNMENT WHEN REPLACING FOUR TIRES, AND TAX. I REALIZE THAT TIRE REPLACEMENT IS JUST ONE PART OF THE OVERALL MAINTENANCE REQUIREMENT FOR A VEHICLE. HOWEVER, TIRES ON A $33,000 VEHICLE SHOULD PROVIDE FAR MORE MILEAGE THAN 24,000 MILES. IN FACT, IF YOU HAVE THE TIME-I INVITE YOU TO GO THE BLOG TITLED TOYOTA NATION, WHERE ALL OF THE WRITERS CONSISTENTLY MAKE DISPARAGING REMARKS ABOUT TOYOTA?S CHEAP TIRE SELECTION. SO MUCH IN FACT, WRITERS DISCUSS VARIOUS METHODS FOR OVERCOMING THE BURDEN OF FINDING A SUITABLE, WELL-PRICED REPLACEMENT WHEN THERE ARE ONLY THREE COMPANIES WHO MAKE THE 245/55-R19. THOSE COMPANIES ARE TOYO, BRIDGESTONE AND HANKOOK. MOST WRITERS CONVERT TO A LARGER TIRE OR A SMALLER TIRE WITH NEW WHEELS, WHICH OF COURSE AFFECTS NOT ONLY THE SPEEDOMETER/ODOMETER READINGS, BUT MORE IMPORTANTLY PERFORMANCE AND POSSIBLY SAFETY OF THE VEHICLE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I BOUGHT MY 2009 JEEP WRANGLER AROUND OCTOBER, NOVEMBER 2009, USED WITH ABOUT 16,000 MILES FROM WORLD CAR NISSAN WITH A ONE HUNDRED THOUSAND MILE WARRANTY. THE JEEP CAME WITH AN AFTER MARKET LIFT KIT OF APPROX 4 INCHES WITH 33 INCH TOYO OPEN COUNTRY TIRES "RANCHO SHOCKS, SKY JACKER LIFT" WORLD CAR TOLD ME THE JEEP CAME LIKE THIS ORIGINALLY FROM THE DEALER. WORLD CAR ENCOURAGED ME TO TAKE THE JEEP AND TEST DRIVE IT FOR A COUPLE OF DAYS. AFTER RETURNING THE JEEP I TOLD THEM THAT I LIKED THE JEEP BUT IT HAD HANDLING ISSUES ON THE ROAD. WHILE TEST DRIVING THE JEEP ON NORMAL ROADS I NOTICED THE JEEP WOULD TRACK HARD AND PULL TO THE LEFT AND TO THE RIGHT ALMOST CAUSING ME TO RUN OFF THE ROAD ON MULTIPLE OCCASIONS. WORLD CAR SAID THEY WOULD CHECK OUT THE FRONT END ALIGNMENT AND BALANCE THE TIRES. I PURCHASED THE JEEP. WHEN PICKING UP THE JEEP THEY TOLD ME THEY TOOK CARE OF ALL THE PROBLEMS. JEEP ASSURED ME THE HANDLING ISSUES WERE DUE TO THE LIFT AND LARGER TIRES. ABOUT TWO WEEKS LATER LEAVING WORK I TURNED A CORNER AND MY RIGHT FRONT TIRE STARTED KLUNKING AND WOBBLING. THE RIGHT FRONT TIRE WAS MISSING 4 OF 5 LUG NUTS AND HAD ONE BROKEN STUD. ONLY ONE LUG NUT WAS HOLDING MY TIRE ON. THE JEEP HAD TO BE TOWED. WORLD CAR GAVE ME A LOANER CAR, REPAIRED THE PROBLEM, WITH NO APOLOGY AND NO EXPLANATION. AROUND JULY 2009, I DROVE TO PORT ARKANSAS TEXAS, I DROVE TO THE BEACH. I ONLY DROVE IN THE NORMAL TRAFFIC LANES NO FOUR WHEELING. THE NEXT WEEK ON FRIDAY WHILE DRIVING DOWN IH 35 THE VEHICLE SUDDENLY JERKED TO THE LEFT ALMOST CAUSING ME TO HAVE AN ACCIDENT. ON SATURDAY I NOTICED THE RIGHT REAR SHOCK HANGING DOWN.THE UPPER SHOCK SUPPORT PIN WAS BROKEN OFF. JEEP ACCUSED ME OF FOUR WHEELING AND ABUSING THE JEEP, THEY REPAIRED IT AT NO COST TO ME. SOME TIMES THE TRACTION CONTROL SYSTEM COMES ON PRE-MATURELY WHILE MAKING CORNERS MAKING THE JEEP HARD TO HANDLE. NOW THE ESP BAS LIGHT CAME ON AND STAYS ON. ON JEEPFORUM.COM ESP BAS FAILURE APPEARS TO BE A COMMON PROBLEM. *TR

TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER HYBRID EQUIPPED WITH TOYO OPEN COUNTRY A20 TIRES. THE CONTACT STATED THAT SHE NOTICED THAT THREE OF THE ORIGINAL TIRES (EXCLUDING THE FRONT PASSENGER BY ANOTHER TIRE MANUFACTURER) ON THE VEHICLE WERE BEGINNING TO SHRED. THE CONTACT STATED THAT IT SEEMED AS IF SOMEONE TOOK A "CHEESE GRATER" TO THE TIRES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE DEALER STATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE OR THE TIRES; THEY DID STATE THAT THEY WOULD REPLACE TWO OF THE TIRES. THE CONTACT HAD NOT SPOKEN WITH THE MANUFACTURER AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 22,000. THE FAILURE MILEAGE WAS APPROXIMATELY 21,000.

WE WERE INFORMED THAT OUR TOYO OPEN COUNTRY H/T 111S OWL 265/70R16 WERE DRY ROTTED. WE PURCHASED THESE TIRES APPROX 2 YEARS AGO AND THE VEHICLE WAS STORED IN CLOSED GARAGE VIRTUALLY EVERY NIGHT. ONLY 30,000 MILES WERE PUT ON THE TIRES FROM POINT OF PURCHASE TO POINT OF OBSERVATION BY TIRE STORE WHICH MEANS DRY ROTTING HAPPENED AT SOME POINT PRIOR TO 30K MILES. IT WAS RECOMMENDED TO US THAT THIS COULD BE A POTENTIALLY DANGEROUS SITUATION FOR ME AND MY FAMILY SO WE ELECTED TO PURCHASE NEW TIRES IMMEDIATELY. *TR

ON 2/26/10, I HAD 4 NEW TIRES INSTALLED IN MY 2005 CIVIC; AT 56,000 MILES. EVEN PURCHASED THE WARRANTY. ABOUT TWO WEEKS LATER, I FELT A VERY MILD VIBRATION BETWEEN 48-52 MPH. I DIDN'T MAKE SUCH A BIG DEAL OF IT THEN. THE PAST 6 WEEKS OR SO, ABOUT 60,000 MILES, THE CIVIC'S VIBRATING HAS GOTTEN WORSE BETWEEN 48-52MPH. I TOOK IT FOR IT'S MAINTENANCE, HAD EVERYTHING DONE, ESPECIALLY THE BREAK ROTORS AND ALIGNMENT. THE VIBRATING HAS NOT STOPPED. I BROUGHT IT BACK TO THE DEALERSHIP. ACCORDING TO THEM, THE CAR WAS CHECKED, AND FELT THE VIBRATING. CAR WAS RE-ALIGNED, THE SAID IT WAS THE REAR STRUTS. I HAD THEM REPLACED WITH A DIFFERENT AUTO MECHANIC, THEN HAD IT RE-ALIGNED ONCE MORE TO ANOTHER AUTO MECHANIC. STILL VIBRATES. BROUGHT IT BACK TO THE MECHANIC WHO INSTALLED THE REAR STRUTS. HE DID A TEST DRIVE, AND BALANCED THE TIRES. THE VIBRATING IS STILL THERE. NOW IT'S BETWEEN 48-60MPH AT RANDOM. SOMETIMES IT DOES IT, SOMETIMES IT'S MILD, SOMETIMES IT STRONGER, DEPENDING AFTER MY APPLY THE BRAKES. THE VIBRATING OCCURS UNDER THE SEATS, FLOOR, REAR, SOME IS FELT VERY MILDLY ON THE DASHBOARD. COULD BE SINCE THE REST OF THE CAR IS VIBRATING. I'M VERY FRUSTRATED. *TR

AT ABOUT 30,000 MILES, I NOTICED CONSIDERABLE VIBRATION AND A THUMPING NOISE, PARTICULARLY PROMINENT IN THE RIGHT FRONT QUADRANT. WHEN THE DEALERSHIP CHECKED THE PROBLEM IT WAS DIAGNOSED AS UNEVEN TIRE WEAR ON THE FRONT TIRES AND I PURCHASED TWO NEW TIRES AND HAD AN ALIGNMENT PERFORMED. THE PROBLEM RECURRED WITHIN 10,000 MILES, AFTER THE NEXT SERVICE. ONCE AGAIN THE DIAGNOSIS WAS UNEVEN TIRE WEAR, THIS TIME ON THE SET OF TIRES WHICH HAD NOT BEEN REPLACED. THE DEALER INDICATED THAT THEY NEEDED TO BE REPLACED AS THEY WERE A SAFETY RISK. ADDITIONALLY THE DEALER INDICATED THAT THE MAZDA 5 WAS HARD ON ITS REAR TIRES (FROM WHICH THESE HAD BEEN ROTATED AT THE LAST SERVICE). A QUICK REVIEW OF A VARIETY OF FORUMS WOULD INDICATE THAT THIS IS A PROBLEM THAT OTHERS HAVE EXPERIENCED AND THAT, IN ADDITION TO THE POOR QUALITY TOYO TIRES WHICH ARE ORIGINAL EQUIPMENT, WEAK ALLOY WHEELS MAY ALSO PLAY A ROLE. *TR

I HAVE A RECENTLY ACQUIRED 1992 HONDA PRELUDE WITH TOYO TIRES ON IT. THE CAR IS NOT BEING DRIVEN AND EXCEPT FOR TWO TRIPS TO MVD TO GET IT REGISTERED IT REMAINS PARKED IN MY DRIVEWAY. THREE WEEKS AGO THE RIGHT REAR TIRE APPARENTLY EXPLODE AND THE TREADS WERE SEPARATED FROM THE TIRE CASING. TWO DAYS AGO I HEARD AN EXPLOSION AND FOUND THAT THE TIRE HAD EXPLODED AND WAS COMPLETELY FLAT. THIS IS THE FIRST TIME I HAVE EVER HEARD OF A TIRE FAILING WHEN THE CAR WAS PARKED. THAT COULD HAVE BEEN THE CAUSE OF QUITE AN ACCIDENT AT 65 MPH ON A CROWDED EXPRESSWAY. IS ANYONE INTERESTED OR SHALL I WAIT FOR THE OTHER THREE TO EXPLODE? I HAVE NO INTENTION OF DRIVING THE CAR WITH THESE TIRES. *TR